Lemon Law Center

Home > Volkswagen

2006 Volkswagen Golf

Component

Service Brakes, Hydraulic:Foundation Components:Master Cylinder

Consequence of Defect

certain cardone master cylinders with date codes lower than dca7078 sold as replacement equipment for use on the vehicles listed above. the seal on master cylinder can fail and leak brake fluid.

Corrective Action

loss of brake fluid can result in poor braking performance, possibly resulting in a vehicle crash.

Recall Notes

cardone will notify owners and offer to repurchase any defective master cylinders. the recall began during april 2007. owners can contact cardone at 1-800-777-4780.

2006 Volkswagen Golf

Component

Exterior Lighting:Brake Lights:Switch

Consequence of Defect

on certain passenger, wagon, and convertible vehicles equipped with or without cruise control, a brake light switch may malfunction if it was installed incorrectly.

Corrective Action

the brake lights could become inoperative, or remain on. failure to provide the proper signal when braking could lead to a crash without warning.

Recall Notes

dealers will install the newly designed brake light switch free of charge. the recall began on april 27, 2007, and will be conducted in several staggered mailings through september 21, 2007. vehicles within the make, model, and model year of this population may be involved in either this recall or 06v-183, but not both. the remedy is the same for each recall. volkswagen dealers will apply the remedy based on the vin number of the vehicle. owners may contact vw at 1-800-822-8987.

2005 Volkswagen Golf

Component

Fuel System, Diesel

Consequence of Defect

on certain passenger vehicles, the high pressure diesel pumps were produced with an improper fastener, which could allow diesel fuel to escape from the pump.

Corrective Action

fuel leakage in the presence of an ignition source may lead to a fire.

Recall Notes

dealers will replace the diesel pump. the recall began on february 8, 2005. owners should contact volkswagen at 1-800-822-8987.

2005 Volkswagen Golf

Component

Service Brakes, Hydraulic:Foundation Components:Master Cylinder

Consequence of Defect

certain cardone master cylinders with date codes lower than dca7078 sold as replacement equipment for use on the vehicles listed above. the seal on master cylinder can fail and leak brake fluid.

Corrective Action

loss of brake fluid can result in poor braking performance, possibly resulting in a vehicle crash.

Recall Notes

cardone will notify owners and offer to repurchase any defective master cylinders. the recall began during april 2007. owners can contact cardone at 1-800-777-4780.

2005 Volkswagen Golf

Component

Exterior Lighting:Brake Lights:Switch

Consequence of Defect

on certain passenger, wagon, and convertible vehicles equipped with or without cruise control, a brake light switch may malfunction if it was installed incorrectly.

Corrective Action

the brake lights could become inoperative, or remain on. failure to provide the proper signal when braking could lead to a crash without warning.

Recall Notes

dealers will install the newly designed brake light switch free of charge. the recall began on april 27, 2007, and will be conducted in several staggered mailings through september 21, 2007. vehicles within the make, model, and model year of this population may be involved in either this recall or 06v-183, but not both. the remedy is the same for each recall. volkswagen dealers will apply the remedy based on the vin number of the vehicle. owners may contact vw at 1-800-822-8987.

2004 Volkswagen Golf

Component

Fuel System, Diesel

Consequence of Defect

on certain passenger vehicles, the high pressure diesel pumps were produced with an improper fastener, which could allow diesel fuel to escape from the pump.

Corrective Action

fuel leakage in the presence of an ignition source may lead to a fire.

Recall Notes

dealers will replace the diesel pump. the recall began on february 8, 2005. owners should contact volkswagen at 1-800-822-8987.

2004 Volkswagen Golf

Component

Service Brakes, Hydraulic:Foundation Components:Master Cylinder

Consequence of Defect

certain cardone master cylinders with date codes lower than dca7078 sold as replacement equipment for use on the vehicles listed above. the seal on master cylinder can fail and leak brake fluid.

Corrective Action

loss of brake fluid can result in poor braking performance, possibly resulting in a vehicle crash.

Recall Notes

cardone will notify owners and offer to repurchase any defective master cylinders. the recall began during april 2007. owners can contact cardone at 1-800-777-4780.

2004 Volkswagen Golf

Component

Exterior Lighting:Brake Lights:Switch

Consequence of Defect

on certain passenger, wagon, and convertible vehicles equipped with or without cruise control, a brake light switch may malfunction if it was installed incorrectly.

Corrective Action

the brake lights could become inoperative, or remain on. failure to provide the proper signal when braking could lead to a crash without warning.

Recall Notes

dealers will install the newly designed brake light switch free of charge. the recall began on april 27, 2007, and will be conducted in several staggered mailings through september 21, 2007. vehicles within the make, model, and model year of this population may be involved in either this recall or 06v-183, but not both. the remedy is the same for each recall. volkswagen dealers will apply the remedy based on the vin number of the vehicle. owners may contact vw at 1-800-822-8987.

2003 Volkswagen Golf

Component

Service Brakes, Hydraulic:Foundation Components:Master Cylinder

Consequence of Defect

certain cardone master cylinders with date codes lower than dca7078 sold as replacement equipment for use on the vehicles listed above. the seal on master cylinder can fail and leak brake fluid.

Corrective Action

loss of brake fluid can result in poor braking performance, possibly resulting in a vehicle crash.

Recall Notes

cardone will notify owners and offer to repurchase any defective master cylinders. the recall began during april 2007. owners can contact cardone at 1-800-777-4780.

2003 Volkswagen Golf

Component

Exterior Lighting:Brake Lights:Switch

Consequence of Defect

on certain passenger, wagon, and convertible vehicles equipped with or without cruise control, a brake light switch may malfunction if it was installed incorrectly.

Corrective Action

the brake lights could become inoperative, or remain on. failure to provide the proper signal when braking could lead to a crash without warning.

Recall Notes

dealers will install the newly designed brake light switch free of charge. the recall began on april 27, 2007, and will be conducted in several staggered mailings through september 21, 2007. vehicles within the make, model, and model year of this population may be involved in either this recall or 06v-183, but not both. the remedy is the same for each recall. volkswagen dealers will apply the remedy based on the vin number of the vehicle. owners may contact vw at 1-800-822-8987.

2002 Volkswagen Golf

Component

Service Brakes, Hydraulic:Antilock

Consequence of Defect

on some passenger vehicles, short circuits can occur within the electronic control unit of the anti-lock braking system (abs).

Corrective Action

this can result in a fire.

Recall Notes

dealers will replace the abs control unit. owner notification began march 8, 2002. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact volkswagen at 1-800-822-8987.

2002 Volkswagen Golf

Component

Service Brakes, Hydraulic:Foundation Components:Master Cylinder

Consequence of Defect

certain cardone master cylinders with date codes lower than dca7078 sold as replacement equipment for use on the vehicles listed above. the seal on master cylinder can fail and leak brake fluid.

Corrective Action

loss of brake fluid can result in poor braking performance, possibly resulting in a vehicle crash.

Recall Notes

cardone will notify owners and offer to repurchase any defective master cylinders. the recall began during april 2007. owners can contact cardone at 1-800-777-4780.

2002 Volkswagen Golf

Component

Exterior Lighting:Hazard Flashing Warning Lights:Switch

Consequence of Defect

on certain passenger vehicles, the hazard switch and flasher system function may degrade over time because of distortion and material transfer of the contacts of certain hazard switch relays which occurs due to substantially increased electrical current load from higher wattage turn signal bulbs.

Corrective Action

this may result in intermittent or inoperative turn signal and hazard flasher function.

Recall Notes

dealers will replace the hazard flasher switch/relay kit. the recall began on march 31, 2005. owners should contact volkswagen at 1-800-822-8987.

2002 Volkswagen Golf

Component

Exterior Lighting:Brake Lights:Switch

Consequence of Defect

on certain passenger, wagon, and convertible vehicles equipped with or without cruise control, a brake light switch may malfunction if it was installed incorrectly.

Corrective Action

the brake lights could become inoperative, or remain on. failure to provide the proper signal when braking could lead to a crash without warning.

Recall Notes

dealers will install the newly designed brake light switch free of charge. the recall began on april 27, 2007, and will be conducted in several staggered mailings through september 21, 2007. vehicles within the make, model, and model year of this population may be involved in either this recall or 06v-183, but not both. the remedy is the same for each recall. volkswagen dealers will apply the remedy based on the vin number of the vehicle. owners may contact vw at 1-800-822-8987.

2001 Volkswagen Golf

Component

Service Brakes, Hydraulic:Antilock

Consequence of Defect

on some passenger vehicles, short circuits can occur within the electronic control unit of the anti-lock braking system (abs).

Corrective Action

this can result in a fire.

Recall Notes

dealers will replace the abs control unit. owner notification began march 8, 2002. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact volkswagen at 1-800-822-8987.

2001 Volkswagen Golf

Component

Equipment:Other:Owners/Service/Other Manual

Consequence of Defect

certain passenger vehicles fail to comply with requirements of federal motor vehicle safety standard no. 225, "child restraint anchorage systems." child seat anchorages installed in the vehicle's rear seats must be identified by markings, and their location and use be described in the owner's manual.

Corrective Action

these vehicles were not marked or described as required by the standard.

Recall Notes

owners will be provided with a supplement for the owner's manual and also one set of four guidance fixtures intended to use in conjunction with child seats equipped with rigid or semi-rigid lower anchorage attachments. also enclosed will be four decals together with installation instructions and a template for attaching the decals to the lower seat backs. owner notification is expected to begin september 15, 2002. owners should contact vwoa at 1-800-822-8987.

2001 Volkswagen Golf

Component

Service Brakes, Hydraulic:Foundation Components:Master Cylinder

Consequence of Defect

certain cardone master cylinders with date codes lower than dca7078 sold as replacement equipment for use on the vehicles listed above. the seal on master cylinder can fail and leak brake fluid.

Corrective Action

loss of brake fluid can result in poor braking performance, possibly resulting in a vehicle crash.

Recall Notes

cardone will notify owners and offer to repurchase any defective master cylinders. the recall began during april 2007. owners can contact cardone at 1-800-777-4780.

2001 Volkswagen Golf

Component

Exterior Lighting:Hazard Flashing Warning Lights:Switch

Consequence of Defect

on certain passenger vehicles, the hazard switch and flasher system function may degrade over time because of distortion and material transfer of the contacts of certain hazard switch relays which occurs due to substantially increased electrical current load from higher wattage turn signal bulbs.

Corrective Action

this may result in intermittent or inoperative turn signal and hazard flasher function.

Recall Notes

dealers will replace the hazard flasher switch/relay kit. the recall began on march 31, 2005. owners should contact volkswagen at 1-800-822-8987.

2001 Volkswagen Golf

Component

Suspension:Front:Control Arm:Upper Arm

Consequence of Defect

vehicle description: passenger vehicles. one of two brackets used to bolt the front suspension control arm in front of the vehicle to the body structure may not have been welded sufficiently.

Corrective Action

the control arm could gradually loosen and ultimately separate from its bracket in normal driving which could cause the vehicle to be difficult to control or result in loss of control. as the bracket loosens, loud metallic knocking sounds in from the vehicle will be heard.

Recall Notes

dealers will inspect the bracket and if the welding is insufficient, will replace the control arm.

2001 Volkswagen Golf

Component

Exterior Lighting:Brake Lights:Switch

Consequence of Defect

on certain passenger, wagon, and convertible vehicles equipped with or without cruise control, a brake light switch may malfunction if it was installed incorrectly.

Corrective Action

the brake lights could become inoperative, or remain on. failure to provide the proper signal when braking could lead to a crash without warning.

Recall Notes

dealers will install the newly designed brake light switch free of charge. the recall began on april 27, 2007, and will be conducted in several staggered mailings through september 21, 2007. vehicles within the make, model, and model year of this population may be involved in either this recall or 06v-183, but not both. the remedy is the same for each recall. volkswagen dealers will apply the remedy based on the vin number of the vehicle. owners may contact vw at 1-800-822-8987.

2000 Volkswagen Golf

Component

Fuel System, Gasoline:Delivery:Fuel Pump

Consequence of Defect

on certain passenger vehicles equipped with gasoline engines and double-layer fuel tanks, tension on the fuel supply line may cause the fuel pump supply nipple to crack which could result in a leak.

Corrective Action

leaking fuel, in the presence of an ignition source, may cause a fire.

Recall Notes

dealers will inspect the fuel supply line for tension, and inspect the fuel pump supply nipple for cracking. if necessary the fuel line and the fuel pump will be replaced free of charge. the recall began on july 25, 2005. owners may contact volkswagen at 1-800-822-8987.

2000 Volkswagen Golf

Component

Equipment:Other:Owners/Service/Other Manual

Consequence of Defect

certain passenger vehicles fail to comply with requirements of federal motor vehicle safety standard no. 225, "child restraint anchorage systems." child seat anchorages installed in the vehicle's rear seats must be identified by markings, and their location and use be described in the owner's manual.

Corrective Action

these vehicles were not marked or described as required by the standard.

Recall Notes

owners will be provided with a supplement for the owner's manual and also one set of four guidance fixtures intended to use in conjunction with child seats equipped with rigid or semi-rigid lower anchorage attachments. also enclosed will be four decals together with installation instructions and a template for attaching the decals to the lower seat backs. owner notification is expected to begin september 15, 2002. owners should contact vwoa at 1-800-822-8987.

2000 Volkswagen Golf

Component

Exterior Lighting:Hazard Flashing Warning Lights:Switch

Consequence of Defect

on certain passenger vehicles, the hazard switch and flasher system function may degrade over time because of distortion and material transfer of the contacts of certain hazard switch relays which occurs due to substantially increased electrical current load from higher wattage turn signal bulbs.

Corrective Action

this may result in intermittent or inoperative turn signal and hazard flasher function.

Recall Notes

dealers will replace the hazard flasher switch/relay kit. the recall began on march 31, 2005. owners should contact volkswagen at 1-800-822-8987.

2000 Volkswagen Golf

Component

Suspension:Front:Control Arm:Upper Arm

Consequence of Defect

vehicle description: passenger vehicles. one of two brackets used to bolt the front suspension control arm in front of the vehicle to the body structure may not have been welded sufficiently.

Corrective Action

the control arm could gradually loosen and ultimately separate from its bracket in normal driving which could cause the vehicle to be difficult to control or result in loss of control. as the bracket loosens, loud metallic knocking sounds in from the vehicle will be heard.

Recall Notes

dealers will inspect the bracket and if the welding is insufficient, will replace the control arm.

2000 Volkswagen Golf

Component

Exterior Lighting:Brake Lights:Switch

Consequence of Defect

on certain passenger, wagon, and convertible vehicles equipped with or without cruise control, a brake light switch may malfunction if it was installed incorrectly.

Corrective Action

the brake lights could become inoperative, or remain on. failure to provide the proper signal when braking could lead to a crash without warning.

Recall Notes

dealers will install the newly designed brake light switch free of charge. the recall began on april 27, 2007, and will be conducted in several staggered mailings through september 21, 2007. vehicles within the make, model, and model year of this population may be involved in either this recall or 06v-183, but not both. the remedy is the same for each recall. volkswagen dealers will apply the remedy based on the vin number of the vehicle. owners may contact vw at 1-800-822-8987.

1999 Volkswagen Golf

Component

Equipment:Other:Labels

Consequence of Defect

certain passenger vehicles equipped with 2.8l vr6 engines fail to comply with the requirements of federal motor vehicle safety standard no. 110, øtire selection and rims.ø the recommended cold tire inflation pressure published on the label for tires of the size 205/50 r15 86h is 0.1 bar (1.45 psi) too low. it should be 2.5 bar (36.3 psi). the label recommends 2.4 bar (34.8 psi = 35 psi).

Corrective Action

under inflated tires can affect vehicle handling, and driving with substantially under inflated tires puts the consumer at risk for a crash.

Recall Notes

owners will be provided with corrected labels, or a dealer can install the label if the owner wishes. owner notification began september 29, 2003. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact vw at 1-800-893-5298.

1999 Volkswagen Golf

Component

Fuel System, Gasoline:Delivery:Fuel Pump

Consequence of Defect

on certain passenger vehicles equipped with gasoline engines and double-layer fuel tanks, tension on the fuel supply line may cause the fuel pump supply nipple to crack which could result in a leak.

Corrective Action

leaking fuel, in the presence of an ignition source, may cause a fire.

Recall Notes

dealers will inspect the fuel supply line for tension, and inspect the fuel pump supply nipple for cracking. if necessary the fuel line and the fuel pump will be replaced free of charge. the recall began on july 25, 2005. owners may contact volkswagen at 1-800-822-8987.

1999 Volkswagen Golf

Component

Structure:Frame And Members

Consequence of Defect

vehicle description: passenger vehicles. the sound absorbing mat attached to the inside of the b-pillar side trim panel could have been improperly installed. surface and edges of the mat could have been damaged during the assembly process. it could ignite when exposed to the exhaust gas of the seat belt pre-tensioner igniter in the event of a severe front or side collision.

Corrective Action

this could result in a fire.

Recall Notes

dealers will remove the matting materials from inside the b-pillar on both sides of the vehicle.

1999 Volkswagen Golf

Component

Exterior Lighting:Brake Lights:Switch

Consequence of Defect

on certain passenger, wagon, and convertible vehicles equipped with or without cruise control, a brake light switch may malfunction if it was installed incorrectly.

Corrective Action

the brake lights could become inoperative, or remain on. failure to provide the proper signal when braking could lead to a crash without warning.

Recall Notes

dealers will install the newly designed brake light switch free of charge. the recall began on april 27, 2007, and will be conducted in several staggered mailings through september 21, 2007. vehicles within the make, model, and model year of this population may be involved in either this recall or 06v-183, but not both. the remedy is the same for each recall. volkswagen dealers will apply the remedy based on the vin number of the vehicle. owners may contact vw at 1-800-822-8987.

1998 Volkswagen Golf

Component

Equipment:Other:Labels

Consequence of Defect

certain passenger vehicles equipped with 2.8l vr6 engines fail to comply with the requirements of federal motor vehicle safety standard no. 110, øtire selection and rims.ø the recommended cold tire inflation pressure published on the label for tires of the size 205/50 r15 86h is 0.1 bar (1.45 psi) too low. it should be 2.5 bar (36.3 psi). the label recommends 2.4 bar (34.8 psi = 35 psi).

Corrective Action

under inflated tires can affect vehicle handling, and driving with substantially under inflated tires puts the consumer at risk for a crash.

Recall Notes

owners will be provided with corrected labels, or a dealer can install the label if the owner wishes. owner notification began september 29, 2003. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact vw at 1-800-893-5298.

1996 Volkswagen Golf

Component

Latches/Locks/Linkages:Hood:Latch

Consequence of Defect

vehicle description: passenger vehicles. the bolts securing the front hood latch can loosen over time. the latch would move causing disengagement of the hood striker from the latch.

Corrective Action

unexpected opening of the hood could occur obstructing the driver's view of the road while driving, increasing the risk of a crash.

Recall Notes

dealers will inspect the hood latch and securing bolts and replace them if necessary.

1995 Volkswagen Golf

Component

Service Brakes, Hydraulic:Foundation Components:Hoses, Lines/Piping, And Fittings

Consequence of Defect

vehicle description: passenger vehicles. the rear brake line on the passenger side was routed too close to the corner of the fuel tank. the line could be damaged by chafing against the fuel tank.

Corrective Action

repeated chafing could eventually result in a leaking brake line causing diminished braking in one brake circuit increasing the vehicle's stopping distance.

Recall Notes

dealers will inspect the brake line and replace any damaged lines.

1995 Volkswagen Golf

Component

Vehicle Speed Control

Consequence of Defect

when installed in the vehicles, a tie wrap is used to guide the cruise control cable in the engine compartment. some tie wraps have been installed with a large loop opening improperly guiding the cable which could prevent the throttle from returning to its full idle position.

Corrective Action

the engine speed may not return to idle increasing thepotential for a vehicle collision.

Recall Notes

dealers will remove the cruise control tie wrap and install a newly designed guide.

1995 Volkswagen Golf

Component

Engine And Engine Cooling:Cooling System:Fan

Consequence of Defect

improper material was used in manufacturing the radiator fan motor shaft causing the shaft to wear and become noisy.

Corrective Action

a worn and noisy fan motor shaft can seize renderingthe fan motor inoperative, eventually causing the engine to overheat and stall. a stalled vehicle in traffic can increase the potential for a vehicle accident.

Recall Notes

dealers will replace the complete cooling fan assembly on vehicle having the potential shaft material problem. dealers will install a new fan blade including a new lock nut on vehicle with loose fan blade lock nuts.

1995 Volkswagen Golf

Component

Latches/Locks/Linkages:Hood:Latch

Consequence of Defect

vehicle description: passenger vehicles. the bolts securing the front hood latch can loosen over time. the latch would move causing disengagement of the hood striker from the latch.

Corrective Action

unexpected opening of the hood could occur obstructing the driver's view of the road while driving, increasing the risk of a crash.

Recall Notes

dealers will inspect the hood latch and securing bolts and replace them if necessary.

1995 Volkswagen Golf

Component

Equipment:Mechanical:Jacks

Consequence of Defect

the jacks supplied with these vehicles were assembled with an improperly machined spindle, so that a sharp ridge on the edge of spindle's thread would have remained.

Corrective Action

this ridge can damage the inside thread of the jack's scissor shoe when the jack is used to lift the vehicle. the jack could collapse with the possibility that a person standing close to the vehicle could be injured.

Recall Notes

owners will be provided with a new jack.

1994 Volkswagen Golf

Component

Service Brakes, Hydraulic:Foundation Components:Hoses, Lines/Piping, And Fittings

Consequence of Defect

vehicle description: passenger vehicles. the rear brake line on the passenger side was routed too close to the corner of the fuel tank. the line could be damaged by chafing against the fuel tank.

Corrective Action

repeated chafing could eventually result in a leaking brake line causing diminished braking in one brake circuit increasing the vehicle's stopping distance.

Recall Notes

dealers will inspect the brake line and replace any damaged lines.

1994 Volkswagen Golf

Component

Vehicle Speed Control

Consequence of Defect

when installed in the vehicles, a tie wrap is used to guide the cruise control cable in the engine compartment. some tie wraps have been installed with a large loop opening improperly guiding the cable which could prevent the throttle from returning to its full idle position.

Corrective Action

the engine speed may not return to idle increasing thepotential for a vehicle collision.

Recall Notes

dealers will remove the cruise control tie wrap and install a newly designed guide.

1994 Volkswagen Golf

Component

Engine And Engine Cooling:Cooling System:Fan

Consequence of Defect

improper material was used in manufacturing the radiator fan motor shaft causing the shaft to wear and become noisy.

Corrective Action

a worn and noisy fan motor shaft can seize renderingthe fan motor inoperative, eventually causing the engine to overheat and stall. a stalled vehicle in traffic can increase the potential for a vehicle accident.

Recall Notes

dealers will replace the complete cooling fan assembly on vehicle having the potential shaft material problem. dealers will install a new fan blade including a new lock nut on vehicle with loose fan blade lock nuts.

1994 Volkswagen Golf

Component

Latches/Locks/Linkages:Hood:Latch

Consequence of Defect

vehicle description: passenger vehicles. the bolts securing the front hood latch can loosen over time. the latch would move causing disengagement of the hood striker from the latch.

Corrective Action

unexpected opening of the hood could occur obstructing the driver's view of the road while driving, increasing the risk of a crash.

Recall Notes

dealers will inspect the hood latch and securing bolts and replace them if necessary.

1994 Volkswagen Golf

Component

Equipment:Mechanical:Jacks

Consequence of Defect

the jacks supplied with these vehicles were assembled with an improperly machined spindle, so that a sharp ridge on the edge of spindle's thread would have remained.

Corrective Action

this ridge can damage the inside thread of the jack's scissor shoe when the jack is used to lift the vehicle. the jack could collapse with the possibility that a person standing close to the vehicle could be injured.

Recall Notes

owners will be provided with a new jack.

1993 Volkswagen Golf

Component

Service Brakes, Hydraulic:Foundation Components:Hoses, Lines/Piping, And Fittings

Consequence of Defect

vehicle description: passenger vehicles. the rear brake line on the passenger side was routed too close to the corner of the fuel tank. the line could be damaged by chafing against the fuel tank.

Corrective Action

repeated chafing could eventually result in a leaking brake line causing diminished braking in one brake circuit increasing the vehicle's stopping distance.

Recall Notes

dealers will inspect the brake line and replace any damaged lines.

1993 Volkswagen Golf

Component

Vehicle Speed Control

Consequence of Defect

when installed in the vehicles, a tie wrap is used to guide the cruise control cable in the engine compartment. some tie wraps have been installed with a large loop opening improperly guiding the cable which could prevent the throttle from returning to its full idle position.

Corrective Action

the engine speed may not return to idle increasing thepotential for a vehicle collision.

Recall Notes

dealers will remove the cruise control tie wrap and install a newly designed guide.

1993 Volkswagen Golf

Component

Engine And Engine Cooling:Cooling System:Fan

Consequence of Defect

improper material was used in manufacturing the radiator fan motor shaft causing the shaft to wear and become noisy.

Corrective Action

a worn and noisy fan motor shaft can seize renderingthe fan motor inoperative, eventually causing the engine to overheat and stall. a stalled vehicle in traffic can increase the potential for a vehicle accident.

Recall Notes

dealers will replace the complete cooling fan assembly on vehicle having the potential shaft material problem. dealers will install a new fan blade including a new lock nut on vehicle with loose fan blade lock nuts.

1993 Volkswagen Golf

Component

Latches/Locks/Linkages:Hood:Latch

Consequence of Defect

vehicle description: passenger vehicles. the bolts securing the front hood latch can loosen over time. the latch would move causing disengagement of the hood striker from the latch.

Corrective Action

unexpected opening of the hood could occur obstructing the driver's view of the road while driving, increasing the risk of a crash.

Recall Notes

dealers will inspect the hood latch and securing bolts and replace them if necessary.

1993 Volkswagen Golf

Component

Equipment:Mechanical:Jacks

Consequence of Defect

the jacks supplied with these vehicles were assembled with an improperly machined spindle, so that a sharp ridge on the edge of spindle's thread would have remained.

Corrective Action

this ridge can damage the inside thread of the jack's scissor shoe when the jack is used to lift the vehicle. the jack could collapse with the possibility that a person standing close to the vehicle could be injured.

Recall Notes

owners will be provided with a new jack.

1992 Volkswagen Golf

Component

Fuel System, Gasoline:Delivery:Hoses, Lines/Piping, And Fittings

Consequence of Defect

the fuel hose attached to the fuel distribution rail on the engine may shrink beyond the clamp force of the fuel hose clamps, allowing fuel to leak.

Corrective Action

fuel leakage in the engine compartment can cause an underhood fire if the fuel comes in contact with a source of ignition.

Recall Notes

replace the fuel hose attached to the fuel rail and install a new spring type self-tightening clamp.

1992 Volkswagen Golf

Component

Service Brakes, Hydraulic

Consequence of Defect

certain hydraulic brake hoses, p/n 171.611.107b, sold as replacement equipment for 1975-1985 volkswagen (vw) rabbit; 1985-1992 vw golf; and 1980-1992 vw jetta passenger vehicles. possible brake hose rupture could occur which fails to comply with the requirements of federal motor vehicle safety standard no. 106, "brake hoses."

Corrective Action

brake hose rupture could result in loss of braking ability, possibly resulting in a vehicle crash.

Recall Notes

foreign parts distributors will notify owners and replace the brake hoses with compliant brake hoses. the recall began on march 30, 2006. owners may contact foreign parts distributors at 305-885-8646 ext. 11.

1991 Volkswagen Golf

Component

Fuel System, Gasoline:Delivery:Hoses, Lines/Piping, And Fittings

Consequence of Defect

the fuel hose attached to the fuel distribution rail on the engine may shrink beyond the clamp force of the fuel hose clamps, allowing fuel to leak.

Corrective Action

fuel leakage in the engine compartment can cause an underhood fire if the fuel comes in contact with a source of ignition.

Recall Notes

replace the fuel hose attached to the fuel rail and install a new spring type self-tightening clamp.

1991 Volkswagen Golf

Component

Service Brakes, Hydraulic

Consequence of Defect

certain hydraulic brake hoses, p/n 171.611.107b, sold as replacement equipment for 1975-1985 volkswagen (vw) rabbit; 1985-1992 vw golf; and 1980-1992 vw jetta passenger vehicles. possible brake hose rupture could occur which fails to comply with the requirements of federal motor vehicle safety standard no. 106, "brake hoses."

Corrective Action

brake hose rupture could result in loss of braking ability, possibly resulting in a vehicle crash.

Recall Notes

foreign parts distributors will notify owners and replace the brake hoses with compliant brake hoses. the recall began on march 30, 2006. owners may contact foreign parts distributors at 305-885-8646 ext. 11.

1991 Volkswagen Golf

Component

Service Brakes, Hydraulic:Foundation Components:Hoses, Lines/Piping, And Fittings

Consequence of Defect

an engine preheating tube may not be properly supported due to a missing support bracket, causing the preheating tube to chafe against the right front metal brake line. this can damage the hydraulic line, causing brake fluid leakage and diminished braking in one brake circuit.

Corrective Action

diminished braking can result in increased stoppingdistances and a possible accident.

Recall Notes

dealers will install a preheating tube support bracket to ensure proper positioning relative to the right front metal brake line.

1990 Volkswagen Golf

Component

Fuel System, Gasoline:Delivery:Hoses, Lines/Piping, And Fittings

Consequence of Defect

the fuel hose attached to the fuel distribution rail on the engine may shrink beyond the clamp force of the fuel hose clamps, allowing fuel to leak.

Corrective Action

fuel leakage in the engine compartment can cause an underhood fire if the fuel comes in contact with a source of ignition.

Recall Notes

replace the fuel hose attached to the fuel rail and install a new spring type self-tightening clamp.

1990 Volkswagen Golf

Component

Service Brakes, Hydraulic

Consequence of Defect

certain hydraulic brake hoses, p/n 171.611.107b, sold as replacement equipment for 1975-1985 volkswagen (vw) rabbit; 1985-1992 vw golf; and 1980-1992 vw jetta passenger vehicles. possible brake hose rupture could occur which fails to comply with the requirements of federal motor vehicle safety standard no. 106, "brake hoses."

Corrective Action

brake hose rupture could result in loss of braking ability, possibly resulting in a vehicle crash.

Recall Notes

foreign parts distributors will notify owners and replace the brake hoses with compliant brake hoses. the recall began on march 30, 2006. owners may contact foreign parts distributors at 305-885-8646 ext. 11.

1990 Volkswagen Golf

Component

Visibility:Defroster/Defogger System:Windshield:Heater Core

Consequence of Defect

the end cap connecting the heat exchanger's core to the engine cooling system could rupture and allow hot coolant to escape into the passenger compartment.

Corrective Action

the coolant escaping into the passenger compartment couldcontact the driver's feet and injure the driver. also, steam from the heatedliquid will cloud on the window surfaces and impair the driver's vision andcould result in a vehicle accident.

Recall Notes

replace the heater core with an improved heater core.

1990 Volkswagen Golf

Component

Service Brakes, Hydraulic:Foundation Components:Disc:Caliper

Consequence of Defect

omission of air ducts intended to guide flow of cooling air to left and right front brake calipers could allow brake fluid to exceed allowable operating temperature under certain operating conditions.

Corrective Action

if brake fluid boils, this could result in reducedbraking pressure with potential for an accident.

Recall Notes

install missing left and right front air ducts.

1990 Volkswagen Golf

Component

Service Brakes, Hydraulic:Foundation Components:Hoses, Lines/Piping, And Fittings

Consequence of Defect

an engine preheating tube may not be properly supported due to a missing support bracket, causing the preheating tube to chafe against the right front metal brake line. this can damage the hydraulic line, causing brake fluid leakage and diminished braking in one brake circuit.

Corrective Action

diminished braking can result in increased stoppingdistances and a possible accident.

Recall Notes

dealers will install a preheating tube support bracket to ensure proper positioning relative to the right front metal brake line.

1989 Volkswagen Golf

Component

Fuel System, Gasoline:Delivery:Hoses, Lines/Piping, And Fittings

Consequence of Defect

the fuel hose attached to the fuel distribution rail on the engine may shrink beyond the clamp force of the fuel hose clamps, allowing fuel to leak.

Corrective Action

fuel leakage in the engine compartment can cause an underhood fire if the fuel comes in contact with a source of ignition.

Recall Notes

replace the fuel hose attached to the fuel rail and install a new spring type self-tightening clamp.

1989 Volkswagen Golf

Component

Service Brakes, Hydraulic

Consequence of Defect

certain hydraulic brake hoses, p/n 171.611.107b, sold as replacement equipment for 1975-1985 volkswagen (vw) rabbit; 1985-1992 vw golf; and 1980-1992 vw jetta passenger vehicles. possible brake hose rupture could occur which fails to comply with the requirements of federal motor vehicle safety standard no. 106, "brake hoses."

Corrective Action

brake hose rupture could result in loss of braking ability, possibly resulting in a vehicle crash.

Recall Notes

foreign parts distributors will notify owners and replace the brake hoses with compliant brake hoses. the recall began on march 30, 2006. owners may contact foreign parts distributors at 305-885-8646 ext. 11.

1989 Volkswagen Golf

Component

Visibility:Defroster/Defogger System:Windshield:Heater Core

Consequence of Defect

the end cap connecting the heat exchanger's core to the engine cooling system could rupture and allow hot coolant to escape into the passenger compartment.

Corrective Action

the coolant escaping into the passenger compartment couldcontact the driver's feet and injure the driver. also, steam from the heatedliquid will cloud on the window surfaces and impair the driver's vision andcould result in a vehicle accident.

Recall Notes

replace the heater core with an improved heater core.

1989 Volkswagen Golf

Component

Service Brakes, Hydraulic:Foundation Components:Hoses, Lines/Piping, And Fittings

Consequence of Defect

an engine preheating tube may not be properly supported due to a missing support bracket, causing the preheating tube to chafe against the right front metal brake line. this can damage the hydraulic line, causing brake fluid leakage and diminished braking in one brake circuit.

Corrective Action

diminished braking can result in increased stoppingdistances and a possible accident.

Recall Notes

dealers will install a preheating tube support bracket to ensure proper positioning relative to the right front metal brake line.

1988 Volkswagen Golf

Component

Seat Belts

Consequence of Defect

seat belt retractor pawl may not meet hardening specifications contained in volkswagens design standard.

Corrective Action

vehicles do not meet volkswagens design standard.

Recall Notes

replace front passive restraint seat belt assembly as necessary.

1988 Volkswagen Golf

Component

Fuel System, Gasoline:Delivery:Hoses, Lines/Piping, And Fittings

Consequence of Defect

the fuel hose attached to the fuel distribution rail on the engine may shrink beyond the clamp force of the fuel hose clamps, allowing fuel to leak.

Corrective Action

fuel leakage in the engine compartment can cause an underhood fire if the fuel comes in contact with a source of ignition.

Recall Notes

replace the fuel hose attached to the fuel rail and install a new spring type self-tightening clamp.

1988 Volkswagen Golf

Component

Service Brakes, Hydraulic

Consequence of Defect

certain hydraulic brake hoses, p/n 171.611.107b, sold as replacement equipment for 1975-1985 volkswagen (vw) rabbit; 1985-1992 vw golf; and 1980-1992 vw jetta passenger vehicles. possible brake hose rupture could occur which fails to comply with the requirements of federal motor vehicle safety standard no. 106, "brake hoses."

Corrective Action

brake hose rupture could result in loss of braking ability, possibly resulting in a vehicle crash.

Recall Notes

foreign parts distributors will notify owners and replace the brake hoses with compliant brake hoses. the recall began on march 30, 2006. owners may contact foreign parts distributors at 305-885-8646 ext. 11.

1988 Volkswagen Golf

Component

Visibility:Defroster/Defogger System:Windshield:Heater Core

Consequence of Defect

the end cap connecting the heat exchanger's core to the engine cooling system could rupture and allow hot coolant to escape into the passenger compartment.

Corrective Action

the coolant escaping into the passenger compartment couldcontact the driver's feet and injure the driver. also, steam from the heatedliquid will cloud on the window surfaces and impair the driver's vision andcould result in a vehicle accident.

Recall Notes

replace the heater core with an improved heater core.

1988 Volkswagen Golf

Component

Service Brakes, Hydraulic:Foundation Components:Hoses, Lines/Piping, And Fittings

Consequence of Defect

an engine preheating tube may not be properly supported due to a missing support bracket, causing the preheating tube to chafe against the right front metal brake line. this can damage the hydraulic line, causing brake fluid leakage and diminished braking in one brake circuit.

Corrective Action

diminished braking can result in increased stoppingdistances and a possible accident.

Recall Notes

dealers will install a preheating tube support bracket to ensure proper positioning relative to the right front metal brake line.

1988 Volkswagen Golf

Component

Vehicle Speed Control

Consequence of Defect

certain vehicles may not be marked with letters res to identify the resume function as required by fmvss 101.

Corrective Action

vehicles do not comply with fmvss 101.

Recall Notes

replace part of cruise switch portion.

1987 Volkswagen Golf

Component

Service Brakes, Hydraulic

Consequence of Defect

certain hydraulic brake hoses, p/n 171.611.107b, sold as replacement equipment for 1975-1985 volkswagen (vw) rabbit; 1985-1992 vw golf; and 1980-1992 vw jetta passenger vehicles. possible brake hose rupture could occur which fails to comply with the requirements of federal motor vehicle safety standard no. 106, "brake hoses."

Corrective Action

brake hose rupture could result in loss of braking ability, possibly resulting in a vehicle crash.

Recall Notes

foreign parts distributors will notify owners and replace the brake hoses with compliant brake hoses. the recall began on march 30, 2006. owners may contact foreign parts distributors at 305-885-8646 ext. 11.

1987 Volkswagen Golf

Component

Visibility:Defroster/Defogger System:Windshield:Heater Core

Consequence of Defect

the end cap connecting the heat exchanger's core to the engine cooling system could rupture and allow hot coolant to escape into the passenger compartment.

Corrective Action

the coolant escaping into the passenger compartment couldcontact the driver's feet and injure the driver. also, steam from the heatedliquid will cloud on the window surfaces and impair the driver's vision andcould result in a vehicle accident.

Recall Notes

replace the heater core with an improved heater core.

1987 Volkswagen Golf

Component

Wheels:Lugs/Nuts/Bolts

Consequence of Defect

the front left wheel lug nuts may have been improperly torqued.

Corrective Action

an improperly torqued wheel may loosen over a period oftime and could eventually separate, causing an accident.

Recall Notes

inspect and re-torque left front wheel lug nuts.

1987 Volkswagen Golf

Component

Fuel System, Gasoline:Delivery:Fuel Pump

Consequence of Defect

fuel pump, located inside fuel tank, could seize during high ambient temperatures because of an extreme fine mesh fuel filter restricting the fuel flow.

Corrective Action

fuel supply to engine would be partially interrupted,resulting in stalling.

Recall Notes

install a modified fuel pump and filter.

1986 Volkswagen Golf

Component

Fuel System, Gasoline:Storage:Tank Assembly

Consequence of Defect

more fuel than permitted by fmvss 301 may escape from the fuel tank assembly under the test conditions described in the standard. consequence of defect: if the car is involved in an accident, the fuel spillage may result in a fire.

Corrective Action

Recall Notes

replace the fuel tank assembly with a modified unit.

1986 Volkswagen Golf

Component

Fuel System, Gasoline:Storage:Tank Assembly

Consequence of Defect

more fuel than permitted by fmvss 301 may escape from the fuel tank assembly. consequence of defect: cars are not in compliance with fmvss 301.

Corrective Action

Recall Notes

replace the fuel tank assembly with a modified unit.

1986 Volkswagen Golf

Component

Service Brakes, Hydraulic

Consequence of Defect

certain hydraulic brake hoses, p/n 171.611.107b, sold as replacement equipment for 1975-1985 volkswagen (vw) rabbit; 1985-1992 vw golf; and 1980-1992 vw jetta passenger vehicles. possible brake hose rupture could occur which fails to comply with the requirements of federal motor vehicle safety standard no. 106, "brake hoses."

Corrective Action

brake hose rupture could result in loss of braking ability, possibly resulting in a vehicle crash.

Recall Notes

foreign parts distributors will notify owners and replace the brake hoses with compliant brake hoses. the recall began on march 30, 2006. owners may contact foreign parts distributors at 305-885-8646 ext. 11.

1986 Volkswagen Golf

Component

Visibility:Defroster/Defogger System:Windshield:Heater Core

Consequence of Defect

the end cap connecting the heat exchanger's core to the engine cooling system could rupture and allow hot coolant to escape into the passenger compartment.

Corrective Action

the coolant escaping into the passenger compartment couldcontact the driver's feet and injure the driver. also, steam from the heatedliquid will cloud on the window surfaces and impair the driver's vision andcould result in a vehicle accident.

Recall Notes

replace the heater core with an improved heater core.

1986 Volkswagen Golf

Component

Fuel System, Gasoline:Delivery:Fuel Pump

Consequence of Defect

fuel pump, located inside fuel tank, could seize during high ambient temperatures because of an extreme fine mesh fuel filter restricting the fuel flow.

Corrective Action

fuel supply to engine would be partially interrupted,resulting in stalling.

Recall Notes

install a modified fuel pump and filter.

1985 Volkswagen Golf

Component

Seat Belts

Consequence of Defect

front seat belt retractors may not properly lock during sudden heavy brake application or impact due to the interference of two positioning tabs. consequence of defect: the seat belt would not retain the driver or passenger subjecting them to possible injury in case of an accident.

Corrective Action

Recall Notes

replace the front seat belts and modify the retractor positioning tabs.

1985 Volkswagen Golf

Component

Fuel System, Gasoline:Storage:Tank Assembly

Consequence of Defect

more fuel than permitted by fmvss 301 may escape from the fuel tank assembly under the test conditions described in the standard. consequence of defect: if the car is involved in an accident, the fuel spillage may result in a fire.

Corrective Action

Recall Notes

replace the fuel tank assembly with a modified unit.

1985 Volkswagen Golf

Component

Service Brakes, Hydraulic:Foundation Components:Master Cylinder

Consequence of Defect

a defect has been found in the assembly of some master brake cylinders. during assembly, internal parts of the master cylinder (piston cups) may have been interchanged.

Corrective Action

Recall Notes

the master cylinder will be replaced free of charge.

1985 Volkswagen Golf

Component

Service Brakes, Hydraulic

Consequence of Defect

certain hydraulic brake hoses, p/n 171.611.107b, sold as replacement equipment for 1975-1985 volkswagen (vw) rabbit; 1985-1992 vw golf; and 1980-1992 vw jetta passenger vehicles. possible brake hose rupture could occur which fails to comply with the requirements of federal motor vehicle safety standard no. 106, "brake hoses."

Corrective Action

brake hose rupture could result in loss of braking ability, possibly resulting in a vehicle crash.

Recall Notes

foreign parts distributors will notify owners and replace the brake hoses with compliant brake hoses. the recall began on march 30, 2006. owners may contact foreign parts distributors at 305-885-8646 ext. 11.

1985 Volkswagen Golf

Component

Visibility:Defroster/Defogger System:Windshield:Heater Core

Consequence of Defect

the end cap connecting the heat exchanger's core to the engine cooling system could rupture and allow hot coolant to escape into the passenger compartment.

Corrective Action

the coolant escaping into the passenger compartment couldcontact the driver's feet and injure the driver. also, steam from the heatedliquid will cloud on the window surfaces and impair the driver's vision andcould result in a vehicle accident.

Recall Notes

replace the heater core with an improved heater core.

1985 Volkswagen Golf

Component

Fuel System, Gasoline:Delivery:Fuel Pump

Consequence of Defect

fuel pump, located inside fuel tank, could seize during high ambient temperatures because of an extreme fine mesh fuel filter restricting the fuel flow.

Corrective Action

fuel supply to engine would be partially interrupted,resulting in stalling.

Recall Notes

install a modified fuel pump and filter.