Home > Pontiac

1999 Pontiac Trans Sport

Component

Latches/Locks/Linkages:Doors:Latch

Consequence of Defect

on certain minivans equipped with second-row bucket seats or captain's chairs and a power sliding door on the passenger side of the vehicle, a passenger using the interior handle to open the power sliding door could be injured.

Corrective Action

if a passenger uses the interior handle to open the power sliding door and holds onto the handle while it is being opened by the motor, the passenger's arm may be pushed into the seat back or armrest and a wrist or lower arm injury may result.

Recall Notes

dealers will replace the power sliding door interior handle on the passenger-side. if the vehicle is equipped with a power or manual sliding door on the driver-side, the interior handle will also be replaced for appearance reasons. note: before the vehicle is serviced, gm advises owners to not use the interior door handle to open the door. the driver can open and close the door from switches at the driver's position or by using the remote key fob. the driver should tell passengers to use the switch located in front of the door to open or close it. the driver should use the override switch to prevent operation of the power door by children or by others who are not familiar with its use. the owner notification letter mailing will be conducted in phases with the first phase beginning on may 31, 2005. the second phase mailing began on july 18, 2005. the recall began on may 31, 2005. phase 2 began on july 18, 2005. phase 3 (final phase) began on august 24, 2005, to all remaining customers. owners should contact chevrolet at 1-800-630-2438; pontiac at 1-800-620-7668; or oldsmobile at 1-800-630-6537.

1999 Pontiac Trans Sport

Component

Air Bags:Frontal

Consequence of Defect

on certain passenger vehicles and mini vans, the driver's air bag inflator modules could produce excessive internal pressure. in the event of a crash that would trigger a driver's air bag deployment, the increased internal pressure can cause the inflator module to explode.

Corrective Action

metal and plastic debris could cause severe injury to vehicle occupants.

Recall Notes

dealers will replace the driver air bag module. owner notification began february 1, 2002. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact pontiac at 1-800-762-2737.

1998 Pontiac Trans Sport

Component

Power Train:Automatic Transmission

Consequence of Defect

vehicle description: mini vans. these vehicles may have (1) a broken shift cable fitting or (2) loose shift linkage. consequently, moving the shift lever to a 'park' position may not shift the transmission to 'park'.

Corrective Action

the vehicle could roll increasing the risk of a crash.

Recall Notes

dealers will inspect, and replace if necessary, the automatic transaxle range selector cable.

1998 Pontiac Trans Sport

Component

Visibility:Windshield Wiper/Washer:Linkages

Consequence of Defect

vehicle description: passenger mini vans equipped with traction control systems. the windshield wiper linkage arm can contact a brake line which is connected to the traction control system modulator valve. this contact can chafe the brake line resulting in a brake fluid leak.

Corrective Action

brake fluid leakage can cause reduced brake effectiveness and increased stopping distances.

Recall Notes

dealers will install a brake line clip to ensure proper clearance. also the brake lines will be inspected to any damage caused by this condition and will replace any damaged lines.

1998 Pontiac Trans Sport

Component

Fuel System, Other:Storage:Tank Assembly:Pressure Relief Devices

Consequence of Defect

certain delphi fuel pressure regulators, p/nos. fp10020-11b1, fp10026-11b1, and fp10027-11b1, sold after january 9, 2007, as aftermarket equipment for various passenger vehicles listed above. the universal pressure regulators (upr) were produced without an o'ring and retainer.

Corrective Action

fuel may leak, possibly resulting in a fire.

Recall Notes

delphi will notify owners and replace the upr free of charge. the recall began on april 23, 2007. owners can contact delphi at 877-411-8770.

1997 Pontiac Trans Sport

Component

Visibility:Windshield Wiper/Washer:Linkages

Consequence of Defect

vehicle description: passenger mini vans equipped with traction control systems. the windshield wiper linkage arm can contact a brake line which is connected to the traction control system modulator valve. this contact can chafe the brake line resulting in a brake fluid leak.

Corrective Action

brake fluid leakage can cause reduced brake effectiveness and increased stopping distances.

Recall Notes

dealers will install a brake line clip to ensure proper clearance. also the brake lines will be inspected to any damage caused by this condition and will replace any damaged lines.

1997 Pontiac Trans Sport

Component

Fuel System, Other:Storage:Tank Assembly:Pressure Relief Devices

Consequence of Defect

certain delphi fuel pressure regulators, p/nos. fp10020-11b1, fp10026-11b1, and fp10027-11b1, sold after january 9, 2007, as aftermarket equipment for various passenger vehicles listed above. the universal pressure regulators (upr) were produced without an o'ring and retainer.

Corrective Action

fuel may leak, possibly resulting in a fire.

Recall Notes

delphi will notify owners and replace the upr free of charge. the recall began on april 23, 2007. owners can contact delphi at 877-411-8770.

1996 Pontiac Trans Sport

Component

Fuel System, Other:Storage:Tank Assembly:Pressure Relief Devices

Consequence of Defect

certain delphi fuel pressure regulators, p/nos. fp10020-11b1, fp10026-11b1, and fp10027-11b1, sold after january 9, 2007, as aftermarket equipment for various passenger vehicles listed above. the universal pressure regulators (upr) were produced without an o'ring and retainer.

Corrective Action

fuel may leak, possibly resulting in a fire.

Recall Notes

delphi will notify owners and replace the upr free of charge. the recall began on april 23, 2007. owners can contact delphi at 877-411-8770.

1995 Pontiac Trans Sport

Component

Service Brakes, Hydraulic:Pedals And Linkages

Consequence of Defect

improperly manufactured brake pedal arm causes the brake pedal arm to fracture during braking.

Corrective Action

this condition can result in a loss of brake operation increasing braking distance and the potential for a vehicle accident.

Recall Notes

dealers will replace all suspect brake pedal assemblies.

1995 Pontiac Trans Sport

Component

Vehicle Speed Control

Consequence of Defect

these vehicles were assembled with throttle cable support brackets that could contact the throttle lever system and inhibit the throttle return. this does not meet the requirements of fmvss no. 124, "accelerator control systems."

Corrective Action

consequence of non-compliance: the throttle may faitl to return quickly causing the engine speed to not decrease to a level anticipated by the driver.

Recall Notes

dealers will replace the throttle cable support bracket.

1995 Pontiac Trans Sport

Component

Power Train:Automatic Transmission:Cooling Unit And Lines

Consequence of Defect

vehicle description: passenger vehicles manufactured from august 1991 through july 1995. the transmission oil cooler line can separate when the vehicle is operated in low temperatures in combination with high transmission loads.

Corrective Action

vehicle fires can occur due to the spillage of transmission fluid.

Recall Notes

dealers will replace the transmission oil cooler lines.

1994 Pontiac Trans Sport

Component

Seat Belts:Front:Webbing

Consequence of Defect

the second row, right hand shoulder belt can become "pinched" between the seat and the door frame pillar trim. the shoulder belt may not retract properly, which does not comply with the requirements of fmvss no. 208, "occupant crash protection." the 1994 vehicles have an optional integral (built in) childseat installed next to the power sliding side door. the 1993 involved vehicles have standard seats in that same position.

Corrective Action

improper shoulder belt retraction does not provide adequate protection to the seat occupant in the event of a sudden stop or collision.

Recall Notes

dealers will replace the door frame pillar trim panel with a redesigned trim panel. also, a caution label will be applied to the child seat advising the owner not to install the seat to the passenger side of a vehicle with a power sliding side door.

1994 Pontiac Trans Sport

Component

Seat Belts:Rear

Consequence of Defect

the safety belt retractors for the rear center position are missing a pawl spring and in case of an accident, will allow the safety belt webbing to extend beyond the minimum requirements of fmvss no. 208, "occupant crash protection."

Corrective Action

in the event of an accident the safety belt would notrestrain the occupant, subjecting the occupant to increased risk of injuries.

Recall Notes

dealers will inspect the safety belt retractor assembly and replace the retractor if the pawl spring is missing.

1994 Pontiac Trans Sport

Component

Seat Belts:Front:Retractor

Consequence of Defect

the third row safety belt retractors may be installed incorrectly and may lock-up when the vehicle is on slopes of less than 15 degrees, which does not comply with fmvss no. 209, "seat belt assemblies."

Corrective Action

consequence of non-compliance: passengers seated in these positon maybe unable to extract and fasten their seat belts until the vehicle is moved to a more level surface. unbelted occupants are more at risk of injury in the event of a collision than those using safety belts.

Recall Notes

dealers will remove third row safety belt retractors and reinstall them properly.

1994 Pontiac Trans Sport

Component

Power Train:Automatic Transmission:Cooling Unit And Lines

Consequence of Defect

vehicle description: passenger vehicles manufactured from august 1991 through july 1995. the transmission oil cooler line can separate when the vehicle is operated in low temperatures in combination with high transmission loads.

Corrective Action

vehicle fires can occur due to the spillage of transmission fluid.

Recall Notes

dealers will replace the transmission oil cooler lines.

1993 Pontiac Trans Sport

Component

Seat Belts:Front:Webbing

Consequence of Defect

the second row, right hand shoulder belt can become "pinched" between the seat and the door frame pillar trim. the shoulder belt may not retract properly, which does not comply with the requirements of fmvss no. 208, "occupant crash protection." the 1994 vehicles have an optional integral (built in) childseat installed next to the power sliding side door. the 1993 involved vehicles have standard seats in that same position.

Corrective Action

improper shoulder belt retraction does not provide adequate protection to the seat occupant in the event of a sudden stop or collision.

Recall Notes

dealers will replace the door frame pillar trim panel with a redesigned trim panel. also, a caution label will be applied to the child seat advising the owner not to install the seat to the passenger side of a vehicle with a power sliding side door.

1993 Pontiac Trans Sport

Component

Seat Belts:Rear

Consequence of Defect

vehicle fails to conform to fmvss no. 209, "seat belt assemblies." the safety belt of the left third row seat on the six passenger van and the center second row seat of the seven passenger van may lock up and cannot be withdrawn from the retractor.

Corrective Action

consequence of non-compliance: the occupants of these seats will not be able to use the affected belt. in the event of a vehicle crash, unbelted occupants are at increased risk of injury.

Recall Notes

owners are being asked to inspect their vehicles to determine if the suspect retractor exhibits a lockup condition. based on this inspection, dealers will replace the safety belts if the belt locks up. replacement of the suspect safety belt will be available to consumers for the life of the vehicle.

1993 Pontiac Trans Sport

Component

Power Train:Automatic Transmission:Cooling Unit And Lines

Consequence of Defect

vehicle description: passenger vehicles manufactured from august 1991 through july 1995. the transmission oil cooler line can separate when the vehicle is operated in low temperatures in combination with high transmission loads.

Corrective Action

vehicle fires can occur due to the spillage of transmission fluid.

Recall Notes

dealers will replace the transmission oil cooler lines.

1992 Pontiac Trans Sport

Component

Seat Belts:Rear

Consequence of Defect

vehicle fails to conform to fmvss no. 209, "seat belt assemblies." the safety belt of the left third row seat on the six passenger van and the center second row seat of the seven passenger van may lock up and cannot be withdrawn from the retractor.

Corrective Action

consequence of non-compliance: the occupants of these seats will not be able to use the affected belt. in the event of a vehicle crash, unbelted occupants are at increased risk of injury.

Recall Notes

owners are being asked to inspect their vehicles to determine if the suspect retractor exhibits a lockup condition. based on this inspection, dealers will replace the safety belts if the belt locks up. replacement of the suspect safety belt will be available to consumers for the life of the vehicle.

1992 Pontiac Trans Sport

Component

Power Train:Automatic Transmission:Cooling Unit And Lines

Consequence of Defect

vehicle description: passenger vehicles manufactured from august 1991 through july 1995. the transmission oil cooler line can separate when the vehicle is operated in low temperatures in combination with high transmission loads.

Corrective Action

vehicle fires can occur due to the spillage of transmission fluid.

Recall Notes

dealers will replace the transmission oil cooler lines.

1991 Pontiac Trans Sport

Component

Seats

Consequence of Defect

this is not a safety recall in accordance with the safety act. however, it is deemed a safety improvement campaign by the agency. vehicle description: minivans equipped with front bucket seats. the front seat recliner mechanism lower bolts can loosen. a loose bolt could fatigue and break, resulting in the seat back falling rearward.

Corrective Action

the seat could suddenly fall backward, distracting the driver, increasing the risk of a crash.

Recall Notes

dealers will tighten or replace the bolts at no charge to the owners. this policy is in effect until june 30, 2002.

1991 Pontiac Trans Sport

Component

Structure:Body

Consequence of Defect

the glove compartment door will not remain closed during certain load forces associated with a vehicle crash. this does not comply with the requirements of fmvss 201.

Corrective Action

in the event of an accident, the glove compartment doormay open and result in occupant(s) injuries from contact with the glovecompartment door.

Recall Notes

replace the current upper glove compartment door with a redesigned upper glove compartment door which incorporates a positive latch to keep the door closed should a vehicle crash occur.

1991 Pontiac Trans Sport

Component

Structure

Consequence of Defect

vehicle description: passenger vehicles and mini vans originally sold or currently registered in the following states: connecticut, illinois, indiana, maine, massachusetts, michigan, new hampshire, new jersey, new york, ohio, pennsylvania, rhode island, vermont and wisconsin. the rear cradle bolts pull through the retainers due to corrosion of the retainer. if both bolts pull through, the rear cradle would not longer be supported at these mounting locations and the steering intermediate shaft can separate from the steering gear.

Corrective Action

if this were to occur while the vehicle was in motion, a vehicle crash could result.

Recall Notes

dealers will replace the rear cradle bolts and retainers.

1990 Pontiac Trans Sport

Component

Seats

Consequence of Defect

the rear modular seat frame hold-down hooks may not meet the required pull force at the rear set anchorage.

Corrective Action

vehicles would not conform to fmvss 207.

Recall Notes

replace rear hold down hooks and pivot rivets with heat treated hardware.

1990 Pontiac Trans Sport

Component

Seats

Consequence of Defect

this is not a safety recall in accordance with the safety act. however, it is deemed a safety improvement campaign by the agency. vehicle description: minivans equipped with front bucket seats. the front seat recliner mechanism lower bolts can loosen. a loose bolt could fatigue and break, resulting in the seat back falling rearward.

Corrective Action

the seat could suddenly fall backward, distracting the driver, increasing the risk of a crash.

Recall Notes

dealers will tighten or replace the bolts at no charge to the owners. this policy is in effect until june 30, 2002.

1990 Pontiac Trans Sport

Component

Structure:Body

Consequence of Defect

the glove compartment door will not remain closed during certain load forces associated with a vehicle crash. this does not comply with the requirements of fmvss 201.

Corrective Action

in the event of an accident, the glove compartment doormay open and result in occupant(s) injuries from contact with the glovecompartment door.

Recall Notes

replace the current upper glove compartment door with a redesigned upper glove compartment door which incorporates a positive latch to keep the door closed should a vehicle crash occur.

1990 Pontiac Trans Sport

Component

Structure

Consequence of Defect

vehicle description: passenger vehicles and mini vans originally sold or currently registered in the following states: connecticut, illinois, indiana, maine, massachusetts, michigan, new hampshire, new jersey, new york, ohio, pennsylvania, rhode island, vermont and wisconsin. the rear cradle bolts pull through the retainers due to corrosion of the retainer. if both bolts pull through, the rear cradle would not longer be supported at these mounting locations and the steering intermediate shaft can separate from the steering gear.

Corrective Action

if this were to occur while the vehicle was in motion, a vehicle crash could result.

Recall Notes

dealers will replace the rear cradle bolts and retainers.

1990 Pontiac Trans Sport

Component

Seat Belts:Front:Anchorage

Consequence of Defect

a right hand seat/shoulder belt retractor may have been installed in the second row left hand seat position (directly behind driver).

Corrective Action

the incorrect retractor may cause the belts to lock upif the van is parked on a steep grade. as a result of this, the occupant couldnot extend the belt for use.

Recall Notes

replace shoulder belt assembly.