Lemon Law Center

Home > Jeep

2007 Jeep Wrangler

Component

Service Brakes, Hydraulic:Antilock:Control Unit/Module

Consequence of Defect

on certain vehicles, the antilock brake system (abs) control module software may cause the rear brakes to lock up during certain braking conditions.

Corrective Action

this could result in a loss of vehicle control and cause a crash without warning.

Recall Notes

dealers will reprogram the abs electronic control unit. the recall began on february 19, 2007. owners may contact daimlerchrysler at 1-800-853-1403.

2007 Jeep Wrangler

Component

Electrical System

Consequence of Defect

on certain vehicles, the totally integrated power module (tipm) was programmed with software that may allow the engine to stall under certain operating conditions.

Corrective Action

this could cause a crash without warning.

Recall Notes

dealers will reprogram the tipm. the recall began on july 5, 2007. owners may contact daimlerchrysler at 1-800-853-1403.

2007 Jeep Wrangler

Component

Service Brakes, Hydraulic:Antilock:Control Unit/Module

Consequence of Defect

on certain sport utility vehicles, the software programmed into the abs electronic control module may allow a momentary delay in braking when coasting up a hill during certain conditions.

Corrective Action

this could cause a crash without warning.

Recall Notes

dealers will reprogram the abs electronic control module with new software that prevents this condition free of charge. the recall began on october 22, 2007. owners may contact chrysler at 1-800-853-1403.

2006 Jeep Wrangler

Component

Power Train:Automatic Transmission

Consequence of Defect

on certain pickup trucks, sport utility and passenger vehicles equipped with 42rle automatic transmissions, the cup plug that retains the park pawl anchor shaft may be improperly installed. if the shaft moves out of position, the vehicle may not be able to achieve 'park' position.

Corrective Action

if this occurs and the parking brake is not applied, the vehicle may roll away and cause a crash without warning.

Recall Notes

dealers will inspect the transmissions and install a bracket to ensure the park pawl anchor shaft is retained in the proper position. the recall began on november 28, 2005. owners may contact daimlerchrysler at 1-800-853-1403.

2006 Jeep Wrangler

Component

Power Train:Clutch Assembly

Consequence of Defect

on certain sport utility vehicles equipped with 6 speed manual transmissions, the hydraulic clutch master cylinder linkage rod may break. this may not allow disengagement of the clutch when the pedal is depressed.

Corrective Action

unintentional vehicle movement, increased stopping distance, and engine stalling could occur which could result in a crash.

Recall Notes

dealers will replace the clutch master cylinder linkage rod free of charge. the recall began on august 7, 2006. owners may contact daimlerchrysler at 1-800-853-1403.

2005 Jeep Wrangler

Component

Service Brakes, Hydraulic

Consequence of Defect

certain aftermarket brake hydraulic master cylinders sold as replacement brake cylinders for certain ford, daimlerchrysler, and jeep passenger vehicles. these brake cylinders were sold under the brand names of napa, raybestos, aimco, ac delco, carquest, bendix, and wagner. only products that were manufactured from july 27, 2005 through january 17, 2006 (date codes 0529 through 0602) are subject to this recall. when subject to very cold temperatures, an internal seal in the master cylinder could lose flexibility and may cause brake fluid to leak.

Corrective Action

loss of brake fluid can lead to a decrease in brake line pressure and an increase in stopping distance, which can result in a vehicle crash.

Recall Notes

affinia (brake parts, inc.) will replace the subject brake hydraulic master cylinders free of charge. the recall began on march 20, 2006. owners can contact affina group customer service at 1-800-323-0354.

2005 Jeep Wrangler

Component

Power Train:Automatic Transmission

Consequence of Defect

on certain pickup trucks, sport utility and passenger vehicles equipped with 42rle automatic transmissions, the cup plug that retains the park pawl anchor shaft may be improperly installed. if the shaft moves out of position, the vehicle may not be able to achieve 'park' position.

Corrective Action

if this occurs and the parking brake is not applied, the vehicle may roll away and cause a crash without warning.

Recall Notes

dealers will inspect the transmissions and install a bracket to ensure the park pawl anchor shaft is retained in the proper position. the recall began on november 28, 2005. owners may contact daimlerchrysler at 1-800-853-1403.

2004 Jeep Wrangler

Component

Service Brakes, Hydraulic

Consequence of Defect

certain aftermarket brake hydraulic master cylinders sold as replacement brake cylinders for certain ford, daimlerchrysler, and jeep passenger vehicles. these brake cylinders were sold under the brand names of napa, raybestos, aimco, ac delco, carquest, bendix, and wagner. only products that were manufactured from july 27, 2005 through january 17, 2006 (date codes 0529 through 0602) are subject to this recall. when subject to very cold temperatures, an internal seal in the master cylinder could lose flexibility and may cause brake fluid to leak.

Corrective Action

loss of brake fluid can lead to a decrease in brake line pressure and an increase in stopping distance, which can result in a vehicle crash.

Recall Notes

affinia (brake parts, inc.) will replace the subject brake hydraulic master cylinders free of charge. the recall began on march 20, 2006. owners can contact affina group customer service at 1-800-323-0354.

2004 Jeep Wrangler

Component

Fuel System, Gasoline:Delivery:Fuel Pump

Consequence of Defect

certain aftermarket airtex electric fuel pumps installed for use as replacement equipment for certain 1997-2004 jeep wrangler; 1997-2001 jeep cherokee; 1997-2004 jeep grand cherokee; and 2000-2003 dodge dakota vehicles. the plastic electrical grommet connectors at the top of the fuel pump module are not compatible with automotive fuels and may degrade causing a potential leak path for fuel.

Corrective Action

in the presence of an ignition source, a fuel leak could result in a fire.

Recall Notes

airtex will notify its customers and will replace the affected fuel pumps free of charge. the recall began on january 25, 2006. owners may contact airtex customer service department at 1-800-880-3056.

2004 Jeep Wrangler

Component

Equipment:Other:Labels

Consequence of Defect

on certain sport utility vehicles, due to a recent software programming error, the tire, wheel, and inflation pressure information was inadvertently omitted from the vehicle certification label.

Corrective Action

the vehicle owner would not be aware of the tire, wheel, and inflation pressure information for their vehicle.

Recall Notes

owners will be provided with a corrected tire certification label. owner notification began on march 1, 2004. owners should contact daimlerchrysler at 1-800-853-1403.

2003 Jeep Wrangler

Component

Service Brakes, Hydraulic

Consequence of Defect

certain aftermarket brake hydraulic master cylinders sold as replacement brake cylinders for certain ford, daimlerchrysler, and jeep passenger vehicles. these brake cylinders were sold under the brand names of napa, raybestos, aimco, ac delco, carquest, bendix, and wagner. only products that were manufactured from july 27, 2005 through january 17, 2006 (date codes 0529 through 0602) are subject to this recall. when subject to very cold temperatures, an internal seal in the master cylinder could lose flexibility and may cause brake fluid to leak.

Corrective Action

loss of brake fluid can lead to a decrease in brake line pressure and an increase in stopping distance, which can result in a vehicle crash.

Recall Notes

affinia (brake parts, inc.) will replace the subject brake hydraulic master cylinders free of charge. the recall began on march 20, 2006. owners can contact affina group customer service at 1-800-323-0354.

2003 Jeep Wrangler

Component

Fuel System, Gasoline:Delivery:Fuel Pump

Consequence of Defect

certain aftermarket airtex electric fuel pumps installed for use as replacement equipment for certain 1997-2004 jeep wrangler; 1997-2001 jeep cherokee; 1997-2004 jeep grand cherokee; and 2000-2003 dodge dakota vehicles. the plastic electrical grommet connectors at the top of the fuel pump module are not compatible with automotive fuels and may degrade causing a potential leak path for fuel.

Corrective Action

in the presence of an ignition source, a fuel leak could result in a fire.

Recall Notes

airtex will notify its customers and will replace the affected fuel pumps free of charge. the recall began on january 25, 2006. owners may contact airtex customer service department at 1-800-880-3056.

2003 Jeep Wrangler

Component

Equipment

Consequence of Defect

bestop aftermarket rear shell roof racks,manufactured between april 27 and may 20, 2004, designed for use with the bestop hardtop made for the 1986-1995 and 1997-2003 jeep wrangler. the cockpit cover may not stay latched to the roof rack because the latch bracket mispositions the rotary latch to the cockpit cover. as a result, the cockpit cover may not stay latched to the roof rack and could separate from the roof rack. this recall only pertains to aftermarket rear shell roof racks and has no relation to any original equipment installed on jeep wrangler vehicles by daimlerchrysler.

Corrective Action

should this occur, the cockpit could cause injury by striking persons outside the vehicle or could become a distraction or an obstacle to other drivers, possibly resulting in a vehicle crash.

Recall Notes

bestop will notify its customers and provide a repair kit and installation instructions free of charge. owner notification began june 16, 2004. owners who do not receive the free remedy within a reasonable time should contact bestop customer service department at (800) 845-3567.

2003 Jeep Wrangler

Component

Exterior Lighting

Consequence of Defect

certain pro-a motors corner lamps, turn signals, and headlights sold as replacement lamps for use on certain passenger vehicles listed above. some combination lamps that are not equipped with amber side reflectors fail to conform to federal motor vehicle safety standard no. 108, lamps, reflective devices, and associated equipment.

Corrective Action

without the amber reflectors, the vehicle will be poorly illuminated, possibly resulting in a vehicle crash without warning.

Recall Notes

pro-a motors will notify owners and offer to repurchase the lamps. the recall began on april 3, 2006. owners may contact pro-a motors at 323-838-2988.

2002 Jeep Wrangler

Component

Service Brakes, Hydraulic

Consequence of Defect

certain aftermarket brake hydraulic master cylinders sold as replacement brake cylinders for certain ford, daimlerchrysler, and jeep passenger vehicles. these brake cylinders were sold under the brand names of napa, raybestos, aimco, ac delco, carquest, bendix, and wagner. only products that were manufactured from july 27, 2005 through january 17, 2006 (date codes 0529 through 0602) are subject to this recall. when subject to very cold temperatures, an internal seal in the master cylinder could lose flexibility and may cause brake fluid to leak.

Corrective Action

loss of brake fluid can lead to a decrease in brake line pressure and an increase in stopping distance, which can result in a vehicle crash.

Recall Notes

affinia (brake parts, inc.) will replace the subject brake hydraulic master cylinders free of charge. the recall began on march 20, 2006. owners can contact affina group customer service at 1-800-323-0354.

2002 Jeep Wrangler

Component

Fuel System, Gasoline:Delivery:Fuel Pump

Consequence of Defect

certain aftermarket airtex electric fuel pumps installed for use as replacement equipment for certain 1997-2004 jeep wrangler; 1997-2001 jeep cherokee; 1997-2004 jeep grand cherokee; and 2000-2003 dodge dakota vehicles. the plastic electrical grommet connectors at the top of the fuel pump module are not compatible with automotive fuels and may degrade causing a potential leak path for fuel.

Corrective Action

in the presence of an ignition source, a fuel leak could result in a fire.

Recall Notes

airtex will notify its customers and will replace the affected fuel pumps free of charge. the recall began on january 25, 2006. owners may contact airtex customer service department at 1-800-880-3056.

2002 Jeep Wrangler

Component

Equipment

Consequence of Defect

bestop aftermarket rear shell roof racks,manufactured between april 27 and may 20, 2004, designed for use with the bestop hardtop made for the 1986-1995 and 1997-2003 jeep wrangler. the cockpit cover may not stay latched to the roof rack because the latch bracket mispositions the rotary latch to the cockpit cover. as a result, the cockpit cover may not stay latched to the roof rack and could separate from the roof rack. this recall only pertains to aftermarket rear shell roof racks and has no relation to any original equipment installed on jeep wrangler vehicles by daimlerchrysler.

Corrective Action

should this occur, the cockpit could cause injury by striking persons outside the vehicle or could become a distraction or an obstacle to other drivers, possibly resulting in a vehicle crash.

Recall Notes

bestop will notify its customers and provide a repair kit and installation instructions free of charge. owner notification began june 16, 2004. owners who do not receive the free remedy within a reasonable time should contact bestop customer service department at (800) 845-3567.

2002 Jeep Wrangler

Component

Exterior Lighting

Consequence of Defect

certain pro-a motors corner lamps, turn signals, and headlights sold as replacement lamps for use on certain passenger vehicles listed above. some combination lamps that are not equipped with amber side reflectors fail to conform to federal motor vehicle safety standard no. 108, lamps, reflective devices, and associated equipment.

Corrective Action

without the amber reflectors, the vehicle will be poorly illuminated, possibly resulting in a vehicle crash without warning.

Recall Notes

pro-a motors will notify owners and offer to repurchase the lamps. the recall began on april 3, 2006. owners may contact pro-a motors at 323-838-2988.

2002 Jeep Wrangler

Component

Electrical System:Ignition:Switch

Consequence of Defect

on certain sport utility vehicles, water and impurities can enter into the ignition switch, causing a short circuit.

Corrective Action

this could result in a vehicle fire.

Recall Notes

dealers will replace the ignition switch with a redesigned switch. owner notification began april 8, 2002. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact daimlerchrysler at 1-800-853-1403.

2002 Jeep Wrangler

Component

Fuel System, Gasoline:Fuel Injection System:Injectors

Consequence of Defect

on certain sport utility vehicles equipped with a 4.0l engine only, the design of the intake and exhaust manifolds could allow debris to accumulate at the #3 cylinder location.

Corrective Action

this could result in a vehicle fire.

Recall Notes

dealers will install a manifold shield to modify the air flow characteristics and to prevent the accumulation of debris in the area of the #3 cylinder. owner notification began may 13, 2002. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact daimlerchrysler at 1-800-853-1403.

2001 Jeep Wrangler

Component

Service Brakes, Hydraulic

Consequence of Defect

certain aftermarket brake hydraulic master cylinders sold as replacement brake cylinders for certain ford, daimlerchrysler, and jeep passenger vehicles. these brake cylinders were sold under the brand names of napa, raybestos, aimco, ac delco, carquest, bendix, and wagner. only products that were manufactured from july 27, 2005 through january 17, 2006 (date codes 0529 through 0602) are subject to this recall. when subject to very cold temperatures, an internal seal in the master cylinder could lose flexibility and may cause brake fluid to leak.

Corrective Action

loss of brake fluid can lead to a decrease in brake line pressure and an increase in stopping distance, which can result in a vehicle crash.

Recall Notes

affinia (brake parts, inc.) will replace the subject brake hydraulic master cylinders free of charge. the recall began on march 20, 2006. owners can contact affina group customer service at 1-800-323-0354.

2001 Jeep Wrangler

Component

Fuel System, Gasoline:Delivery:Fuel Pump

Consequence of Defect

certain aftermarket airtex electric fuel pumps installed for use as replacement equipment for certain 1997-2004 jeep wrangler; 1997-2001 jeep cherokee; 1997-2004 jeep grand cherokee; and 2000-2003 dodge dakota vehicles. the plastic electrical grommet connectors at the top of the fuel pump module are not compatible with automotive fuels and may degrade causing a potential leak path for fuel.

Corrective Action

in the presence of an ignition source, a fuel leak could result in a fire.

Recall Notes

airtex will notify its customers and will replace the affected fuel pumps free of charge. the recall began on january 25, 2006. owners may contact airtex customer service department at 1-800-880-3056.

2001 Jeep Wrangler

Component

Equipment

Consequence of Defect

bestop aftermarket rear shell roof racks,manufactured between april 27 and may 20, 2004, designed for use with the bestop hardtop made for the 1986-1995 and 1997-2003 jeep wrangler. the cockpit cover may not stay latched to the roof rack because the latch bracket mispositions the rotary latch to the cockpit cover. as a result, the cockpit cover may not stay latched to the roof rack and could separate from the roof rack. this recall only pertains to aftermarket rear shell roof racks and has no relation to any original equipment installed on jeep wrangler vehicles by daimlerchrysler.

Corrective Action

should this occur, the cockpit could cause injury by striking persons outside the vehicle or could become a distraction or an obstacle to other drivers, possibly resulting in a vehicle crash.

Recall Notes

bestop will notify its customers and provide a repair kit and installation instructions free of charge. owner notification began june 16, 2004. owners who do not receive the free remedy within a reasonable time should contact bestop customer service department at (800) 845-3567.

2001 Jeep Wrangler

Component

Exterior Lighting

Consequence of Defect

certain pro-a motors corner lamps, turn signals, and headlights sold as replacement lamps for use on certain passenger vehicles listed above. some combination lamps that are not equipped with amber side reflectors fail to conform to federal motor vehicle safety standard no. 108, lamps, reflective devices, and associated equipment.

Corrective Action

without the amber reflectors, the vehicle will be poorly illuminated, possibly resulting in a vehicle crash without warning.

Recall Notes

pro-a motors will notify owners and offer to repurchase the lamps. the recall began on april 3, 2006. owners may contact pro-a motors at 323-838-2988.

2001 Jeep Wrangler

Component

Electrical System:Ignition:Switch

Consequence of Defect

on certain sport utility vehicles, water and impurities can enter into the ignition switch, causing a short circuit.

Corrective Action

this could result in a vehicle fire.

Recall Notes

dealers will replace the ignition switch with a redesigned switch. owner notification began april 8, 2002. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact daimlerchrysler at 1-800-853-1403.

2001 Jeep Wrangler

Component

Fuel System, Gasoline:Fuel Injection System:Injectors

Consequence of Defect

on certain sport utility vehicles equipped with a 4.0l engine only, the design of the intake and exhaust manifolds could allow debris to accumulate at the #3 cylinder location.

Corrective Action

this could result in a vehicle fire.

Recall Notes

dealers will install a manifold shield to modify the air flow characteristics and to prevent the accumulation of debris in the area of the #3 cylinder. owner notification began may 13, 2002. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact daimlerchrysler at 1-800-853-1403.

2001 Jeep Wrangler

Component

Child Seat

Consequence of Defect

vehicle description: certain passenger vehicles, pickup trucks and sport utility vehicles fail to comply with the requirements of fmvss no. 225, "child restraint anchorage systems." some of the owner's manuals for these vehicles are missing instructions that provide a step-by-step procedure, including diagrams, for properly attaching a child restraint system's tether strap to the tether anchorage.

Corrective Action

in the event of a crash, the child seat may not be properly attached increasing the risk of injury to the child.

Recall Notes

owners will be provided with an addendum to the owner's manuals.

2000 Jeep Wrangler

Component

Service Brakes, Hydraulic

Consequence of Defect

certain aftermarket brake hydraulic master cylinders sold as replacement brake cylinders for certain ford, daimlerchrysler, and jeep passenger vehicles. these brake cylinders were sold under the brand names of napa, raybestos, aimco, ac delco, carquest, bendix, and wagner. only products that were manufactured from july 27, 2005 through january 17, 2006 (date codes 0529 through 0602) are subject to this recall. when subject to very cold temperatures, an internal seal in the master cylinder could lose flexibility and may cause brake fluid to leak.

Corrective Action

loss of brake fluid can lead to a decrease in brake line pressure and an increase in stopping distance, which can result in a vehicle crash.

Recall Notes

affinia (brake parts, inc.) will replace the subject brake hydraulic master cylinders free of charge. the recall began on march 20, 2006. owners can contact affina group customer service at 1-800-323-0354.

2000 Jeep Wrangler

Component

Fuel System, Gasoline:Delivery:Fuel Pump

Consequence of Defect

certain aftermarket airtex electric fuel pumps installed for use as replacement equipment for certain 1997-2004 jeep wrangler; 1997-2001 jeep cherokee; 1997-2004 jeep grand cherokee; and 2000-2003 dodge dakota vehicles. the plastic electrical grommet connectors at the top of the fuel pump module are not compatible with automotive fuels and may degrade causing a potential leak path for fuel.

Corrective Action

in the presence of an ignition source, a fuel leak could result in a fire.

Recall Notes

airtex will notify its customers and will replace the affected fuel pumps free of charge. the recall began on january 25, 2006. owners may contact airtex customer service department at 1-800-880-3056.

2000 Jeep Wrangler

Component

Equipment

Consequence of Defect

bestop aftermarket rear shell roof racks,manufactured between april 27 and may 20, 2004, designed for use with the bestop hardtop made for the 1986-1995 and 1997-2003 jeep wrangler. the cockpit cover may not stay latched to the roof rack because the latch bracket mispositions the rotary latch to the cockpit cover. as a result, the cockpit cover may not stay latched to the roof rack and could separate from the roof rack. this recall only pertains to aftermarket rear shell roof racks and has no relation to any original equipment installed on jeep wrangler vehicles by daimlerchrysler.

Corrective Action

should this occur, the cockpit could cause injury by striking persons outside the vehicle or could become a distraction or an obstacle to other drivers, possibly resulting in a vehicle crash.

Recall Notes

bestop will notify its customers and provide a repair kit and installation instructions free of charge. owner notification began june 16, 2004. owners who do not receive the free remedy within a reasonable time should contact bestop customer service department at (800) 845-3567.

2000 Jeep Wrangler

Component

Exterior Lighting

Consequence of Defect

certain pro-a motors corner lamps, turn signals, and headlights sold as replacement lamps for use on certain passenger vehicles listed above. some combination lamps that are not equipped with amber side reflectors fail to conform to federal motor vehicle safety standard no. 108, lamps, reflective devices, and associated equipment.

Corrective Action

without the amber reflectors, the vehicle will be poorly illuminated, possibly resulting in a vehicle crash without warning.

Recall Notes

pro-a motors will notify owners and offer to repurchase the lamps. the recall began on april 3, 2006. owners may contact pro-a motors at 323-838-2988.

2000 Jeep Wrangler

Component

Fuel System, Gasoline:Fuel Injection System:Injectors

Consequence of Defect

on certain sport utility vehicles equipped with a 4.0l engine only, the design of the intake and exhaust manifolds could allow debris to accumulate at the #3 cylinder location.

Corrective Action

this could result in a vehicle fire.

Recall Notes

dealers will install a manifold shield to modify the air flow characteristics and to prevent the accumulation of debris in the area of the #3 cylinder. owner notification began may 13, 2002. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact daimlerchrysler at 1-800-853-1403.

1999 Jeep Wrangler

Component

Service Brakes, Hydraulic

Consequence of Defect

certain aftermarket brake hydraulic master cylinders sold as replacement brake cylinders for certain ford, daimlerchrysler, and jeep passenger vehicles. these brake cylinders were sold under the brand names of napa, raybestos, aimco, ac delco, carquest, bendix, and wagner. only products that were manufactured from july 27, 2005 through january 17, 2006 (date codes 0529 through 0602) are subject to this recall. when subject to very cold temperatures, an internal seal in the master cylinder could lose flexibility and may cause brake fluid to leak.

Corrective Action

loss of brake fluid can lead to a decrease in brake line pressure and an increase in stopping distance, which can result in a vehicle crash.

Recall Notes

affinia (brake parts, inc.) will replace the subject brake hydraulic master cylinders free of charge. the recall began on march 20, 2006. owners can contact affina group customer service at 1-800-323-0354.

1999 Jeep Wrangler

Component

Fuel System, Gasoline:Delivery:Fuel Pump

Consequence of Defect

certain aftermarket airtex electric fuel pumps installed for use as replacement equipment for certain 1997-2004 jeep wrangler; 1997-2001 jeep cherokee; 1997-2004 jeep grand cherokee; and 2000-2003 dodge dakota vehicles. the plastic electrical grommet connectors at the top of the fuel pump module are not compatible with automotive fuels and may degrade causing a potential leak path for fuel.

Corrective Action

in the presence of an ignition source, a fuel leak could result in a fire.

Recall Notes

airtex will notify its customers and will replace the affected fuel pumps free of charge. the recall began on january 25, 2006. owners may contact airtex customer service department at 1-800-880-3056.

1999 Jeep Wrangler

Component

Other

Consequence of Defect

vehicle description: sport utility vehicles. the left side and right side instrument panel wiring ground attachment screws could loosen over time.

Corrective Action

if the left side screw loosens, the instrument panel gauges may not function when the headlamps are turned on. if the right side screw loosens, the defroster blower motor may not function.

Recall Notes

dealers will remove the ground screws, drill a new pilot hole adjacent to the original hole, and the screws will be reinstalled in the new holes.

1999 Jeep Wrangler

Component

Equipment

Consequence of Defect

bestop aftermarket rear shell roof racks,manufactured between april 27 and may 20, 2004, designed for use with the bestop hardtop made for the 1986-1995 and 1997-2003 jeep wrangler. the cockpit cover may not stay latched to the roof rack because the latch bracket mispositions the rotary latch to the cockpit cover. as a result, the cockpit cover may not stay latched to the roof rack and could separate from the roof rack. this recall only pertains to aftermarket rear shell roof racks and has no relation to any original equipment installed on jeep wrangler vehicles by daimlerchrysler.

Corrective Action

should this occur, the cockpit could cause injury by striking persons outside the vehicle or could become a distraction or an obstacle to other drivers, possibly resulting in a vehicle crash.

Recall Notes

bestop will notify its customers and provide a repair kit and installation instructions free of charge. owner notification began june 16, 2004. owners who do not receive the free remedy within a reasonable time should contact bestop customer service department at (800) 845-3567.

1999 Jeep Wrangler

Component

Exterior Lighting

Consequence of Defect

certain pro-a motors corner lamps, turn signals, and headlights sold as replacement lamps for use on certain passenger vehicles listed above. some combination lamps that are not equipped with amber side reflectors fail to conform to federal motor vehicle safety standard no. 108, lamps, reflective devices, and associated equipment.

Corrective Action

without the amber reflectors, the vehicle will be poorly illuminated, possibly resulting in a vehicle crash without warning.

Recall Notes

pro-a motors will notify owners and offer to repurchase the lamps. the recall began on april 3, 2006. owners may contact pro-a motors at 323-838-2988.

1998 Jeep Wrangler

Component

Service Brakes, Hydraulic

Consequence of Defect

certain aftermarket brake hydraulic master cylinders sold as replacement brake cylinders for certain ford, daimlerchrysler, and jeep passenger vehicles. these brake cylinders were sold under the brand names of napa, raybestos, aimco, ac delco, carquest, bendix, and wagner. only products that were manufactured from july 27, 2005 through january 17, 2006 (date codes 0529 through 0602) are subject to this recall. when subject to very cold temperatures, an internal seal in the master cylinder could lose flexibility and may cause brake fluid to leak.

Corrective Action

loss of brake fluid can lead to a decrease in brake line pressure and an increase in stopping distance, which can result in a vehicle crash.

Recall Notes

affinia (brake parts, inc.) will replace the subject brake hydraulic master cylinders free of charge. the recall began on march 20, 2006. owners can contact affina group customer service at 1-800-323-0354.

1998 Jeep Wrangler

Component

Fuel System, Gasoline:Delivery:Fuel Pump

Consequence of Defect

certain aftermarket airtex electric fuel pumps installed for use as replacement equipment for certain 1997-2004 jeep wrangler; 1997-2001 jeep cherokee; 1997-2004 jeep grand cherokee; and 2000-2003 dodge dakota vehicles. the plastic electrical grommet connectors at the top of the fuel pump module are not compatible with automotive fuels and may degrade causing a potential leak path for fuel.

Corrective Action

in the presence of an ignition source, a fuel leak could result in a fire.

Recall Notes

airtex will notify its customers and will replace the affected fuel pumps free of charge. the recall began on january 25, 2006. owners may contact airtex customer service department at 1-800-880-3056.

1998 Jeep Wrangler

Component

Seat Belts:Front:Anchorage

Consequence of Defect

vehicle description: multi-purpose passenger vehicle. the front seat belt shoulder turning loop anchors were not properly heat treated and are not properly hardened.

Corrective Action

in the event of a vehicle crash, the front seat occupant may not be properly restrained increasing the risk of serious injury.

Recall Notes

dealers will replace the front seat shoulder belt turning loop on these vehicles.

1998 Jeep Wrangler

Component

Equipment

Consequence of Defect

bestop aftermarket rear shell roof racks,manufactured between april 27 and may 20, 2004, designed for use with the bestop hardtop made for the 1986-1995 and 1997-2003 jeep wrangler. the cockpit cover may not stay latched to the roof rack because the latch bracket mispositions the rotary latch to the cockpit cover. as a result, the cockpit cover may not stay latched to the roof rack and could separate from the roof rack. this recall only pertains to aftermarket rear shell roof racks and has no relation to any original equipment installed on jeep wrangler vehicles by daimlerchrysler.

Corrective Action

should this occur, the cockpit could cause injury by striking persons outside the vehicle or could become a distraction or an obstacle to other drivers, possibly resulting in a vehicle crash.

Recall Notes

bestop will notify its customers and provide a repair kit and installation instructions free of charge. owner notification began june 16, 2004. owners who do not receive the free remedy within a reasonable time should contact bestop customer service department at (800) 845-3567.

1998 Jeep Wrangler

Component

Service Brakes, Hydraulic:Power Assist:Vacuum

Consequence of Defect

vehicle description: multi-purpose passenger vehicles. the power brake booster vacuum reservoir diaphragm can split or tear.

Corrective Action

this can cause an increase in engine idle speed and a loss of power assist during brake application without prior warning.

Recall Notes

dealers will inspect the brake booster date code and any boosters with the suspect manufacturing date range will be replaced.

1998 Jeep Wrangler

Component

Exterior Lighting

Consequence of Defect

certain pro-a motors corner lamps, turn signals, and headlights sold as replacement lamps for use on certain passenger vehicles listed above. some combination lamps that are not equipped with amber side reflectors fail to conform to federal motor vehicle safety standard no. 108, lamps, reflective devices, and associated equipment.

Corrective Action

without the amber reflectors, the vehicle will be poorly illuminated, possibly resulting in a vehicle crash without warning.

Recall Notes

pro-a motors will notify owners and offer to repurchase the lamps. the recall began on april 3, 2006. owners may contact pro-a motors at 323-838-2988.

1997 Jeep Wrangler

Component

Air Bags:Frontal:Sensor/Control Module

Consequence of Defect

the electrical circuit design allows the potential for an inadvertent air bag deployment upon vehicle ignition shut down.

Corrective Action

unexpected air bag deployment can result in occupant injury.

Recall Notes

dealers will replace the air bag electronic control module with a newly designed module.

1997 Jeep Wrangler

Component

Air Bags

Consequence of Defect

the air bag electronic control module (aecm) software contains an error which can delay the air bag deployment in certain crash situations.

Corrective Action

delayed deployment can cause increased injury to front seat vehicle occupants in a collision.

Recall Notes

dealers will replace the air bag electronic control module on these vehicles.

1997 Jeep Wrangler

Component

Service Brakes, Hydraulic

Consequence of Defect

certain aftermarket brake hydraulic master cylinders sold as replacement brake cylinders for certain ford, daimlerchrysler, and jeep passenger vehicles. these brake cylinders were sold under the brand names of napa, raybestos, aimco, ac delco, carquest, bendix, and wagner. only products that were manufactured from july 27, 2005 through january 17, 2006 (date codes 0529 through 0602) are subject to this recall. when subject to very cold temperatures, an internal seal in the master cylinder could lose flexibility and may cause brake fluid to leak.

Corrective Action

loss of brake fluid can lead to a decrease in brake line pressure and an increase in stopping distance, which can result in a vehicle crash.

Recall Notes

affinia (brake parts, inc.) will replace the subject brake hydraulic master cylinders free of charge. the recall began on march 20, 2006. owners can contact affina group customer service at 1-800-323-0354.

1997 Jeep Wrangler

Component

Fuel System, Gasoline:Delivery:Fuel Pump

Consequence of Defect

certain aftermarket airtex electric fuel pumps installed for use as replacement equipment for certain 1997-2004 jeep wrangler; 1997-2001 jeep cherokee; 1997-2004 jeep grand cherokee; and 2000-2003 dodge dakota vehicles. the plastic electrical grommet connectors at the top of the fuel pump module are not compatible with automotive fuels and may degrade causing a potential leak path for fuel.

Corrective Action

in the presence of an ignition source, a fuel leak could result in a fire.

Recall Notes

airtex will notify its customers and will replace the affected fuel pumps free of charge. the recall began on january 25, 2006. owners may contact airtex customer service department at 1-800-880-3056.

1997 Jeep Wrangler

Component

Equipment

Consequence of Defect

bestop aftermarket rear shell roof racks,manufactured between april 27 and may 20, 2004, designed for use with the bestop hardtop made for the 1986-1995 and 1997-2003 jeep wrangler. the cockpit cover may not stay latched to the roof rack because the latch bracket mispositions the rotary latch to the cockpit cover. as a result, the cockpit cover may not stay latched to the roof rack and could separate from the roof rack. this recall only pertains to aftermarket rear shell roof racks and has no relation to any original equipment installed on jeep wrangler vehicles by daimlerchrysler.

Corrective Action

should this occur, the cockpit could cause injury by striking persons outside the vehicle or could become a distraction or an obstacle to other drivers, possibly resulting in a vehicle crash.

Recall Notes

bestop will notify its customers and provide a repair kit and installation instructions free of charge. owner notification began june 16, 2004. owners who do not receive the free remedy within a reasonable time should contact bestop customer service department at (800) 845-3567.

1997 Jeep Wrangler

Component

Exterior Lighting

Consequence of Defect

certain pro-a motors corner lamps, turn signals, and headlights sold as replacement lamps for use on certain passenger vehicles listed above. some combination lamps that are not equipped with amber side reflectors fail to conform to federal motor vehicle safety standard no. 108, lamps, reflective devices, and associated equipment.

Corrective Action

without the amber reflectors, the vehicle will be poorly illuminated, possibly resulting in a vehicle crash without warning.

Recall Notes

pro-a motors will notify owners and offer to repurchase the lamps. the recall began on april 3, 2006. owners may contact pro-a motors at 323-838-2988.

1997 Jeep Wrangler

Component

Air Bags:Frontal

Consequence of Defect

vehicle description: multi-purpose passenger vehicle. the driver's side air bag 'clock spring' wiring harness can break when turned to the 'full lock' turn position.

Corrective Action

in the event of a vehicle crash, the air bag may not deploy increasing the risk of serious injury to the occupant.

Recall Notes

dealers will replace the clock spring in these air bags.

1996 Jeep Wrangler

Component

Exterior Lighting

Consequence of Defect

certain pro-a motors corner lamps, turn signals, and headlights sold as replacement lamps for use on certain passenger vehicles listed above. some combination lamps that are not equipped with amber side reflectors fail to conform to federal motor vehicle safety standard no. 108, lamps, reflective devices, and associated equipment.

Corrective Action

without the amber reflectors, the vehicle will be poorly illuminated, possibly resulting in a vehicle crash without warning.

Recall Notes

pro-a motors will notify owners and offer to repurchase the lamps. the recall began on april 3, 2006. owners may contact pro-a motors at 323-838-2988.

1995 Jeep Wrangler

Component

Parking Brake:Conventional

Consequence of Defect

on certain sport utility vehicles equipped with manual transmissions, the parking brake can self-release without warning.

Corrective Action

this could allow the vehicle to roll away, increasing the risk of a crash.

Recall Notes

dealers will install a parking brake assembly with a stronger pawl return spring. owner notificaton began september 30, 2002. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact daimlerchrysler at 1-800-853-1403.

1995 Jeep Wrangler

Component

Equipment

Consequence of Defect

bestop aftermarket rear shell roof racks,manufactured between april 27 and may 20, 2004, designed for use with the bestop hardtop made for the 1986-1995 and 1997-2003 jeep wrangler. the cockpit cover may not stay latched to the roof rack because the latch bracket mispositions the rotary latch to the cockpit cover. as a result, the cockpit cover may not stay latched to the roof rack and could separate from the roof rack. this recall only pertains to aftermarket rear shell roof racks and has no relation to any original equipment installed on jeep wrangler vehicles by daimlerchrysler.

Corrective Action

should this occur, the cockpit could cause injury by striking persons outside the vehicle or could become a distraction or an obstacle to other drivers, possibly resulting in a vehicle crash.

Recall Notes

bestop will notify its customers and provide a repair kit and installation instructions free of charge. owner notification began june 16, 2004. owners who do not receive the free remedy within a reasonable time should contact bestop customer service department at (800) 845-3567.

1995 Jeep Wrangler

Component

Exterior Lighting

Consequence of Defect

certain pro-a motors corner lamps, turn signals, and headlights sold as replacement lamps for use on certain passenger vehicles listed above. some combination lamps that are not equipped with amber side reflectors fail to conform to federal motor vehicle safety standard no. 108, lamps, reflective devices, and associated equipment.

Corrective Action

without the amber reflectors, the vehicle will be poorly illuminated, possibly resulting in a vehicle crash without warning.

Recall Notes

pro-a motors will notify owners and offer to repurchase the lamps. the recall began on april 3, 2006. owners may contact pro-a motors at 323-838-2988.

1994 Jeep Wrangler

Component

Parking Brake:Conventional

Consequence of Defect

on certain sport utility vehicles equipped with manual transmissions, the parking brake can self-release without warning.

Corrective Action

this could allow the vehicle to roll away, increasing the risk of a crash.

Recall Notes

dealers will install a parking brake assembly with a stronger pawl return spring. owner notificaton began september 30, 2002. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact daimlerchrysler at 1-800-853-1403.

1994 Jeep Wrangler

Component

Equipment

Consequence of Defect

bestop aftermarket rear shell roof racks,manufactured between april 27 and may 20, 2004, designed for use with the bestop hardtop made for the 1986-1995 and 1997-2003 jeep wrangler. the cockpit cover may not stay latched to the roof rack because the latch bracket mispositions the rotary latch to the cockpit cover. as a result, the cockpit cover may not stay latched to the roof rack and could separate from the roof rack. this recall only pertains to aftermarket rear shell roof racks and has no relation to any original equipment installed on jeep wrangler vehicles by daimlerchrysler.

Corrective Action

should this occur, the cockpit could cause injury by striking persons outside the vehicle or could become a distraction or an obstacle to other drivers, possibly resulting in a vehicle crash.

Recall Notes

bestop will notify its customers and provide a repair kit and installation instructions free of charge. owner notification began june 16, 2004. owners who do not receive the free remedy within a reasonable time should contact bestop customer service department at (800) 845-3567.

1994 Jeep Wrangler

Component

Fuel System, Gasoline:Delivery:Fuel Pump

Consequence of Defect

vehicle description: multipurpose passenger vehicles equipped with plastic fuel tanks. the fuel tank sending unit gasket can crack causing fuel and fuel vapor leaks.

Corrective Action

fuel and fuel vapor leaked from the fuel tank can result in fire when exposed to a source of ignition.

Recall Notes

replace the fuel tank sending unit gasket.

1994 Jeep Wrangler

Component

Exterior Lighting

Consequence of Defect

certain pro-a motors corner lamps, turn signals, and headlights sold as replacement lamps for use on certain passenger vehicles listed above. some combination lamps that are not equipped with amber side reflectors fail to conform to federal motor vehicle safety standard no. 108, lamps, reflective devices, and associated equipment.

Corrective Action

without the amber reflectors, the vehicle will be poorly illuminated, possibly resulting in a vehicle crash without warning.

Recall Notes

pro-a motors will notify owners and offer to repurchase the lamps. the recall began on april 3, 2006. owners may contact pro-a motors at 323-838-2988.

1993 Jeep Wrangler

Component

Parking Brake:Conventional

Consequence of Defect

on certain sport utility vehicles equipped with manual transmissions, the parking brake can self-release without warning.

Corrective Action

this could allow the vehicle to roll away, increasing the risk of a crash.

Recall Notes

dealers will install a parking brake assembly with a stronger pawl return spring. owner notificaton began september 30, 2002. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact daimlerchrysler at 1-800-853-1403.

1993 Jeep Wrangler

Component

Equipment

Consequence of Defect

bestop aftermarket rear shell roof racks,manufactured between april 27 and may 20, 2004, designed for use with the bestop hardtop made for the 1986-1995 and 1997-2003 jeep wrangler. the cockpit cover may not stay latched to the roof rack because the latch bracket mispositions the rotary latch to the cockpit cover. as a result, the cockpit cover may not stay latched to the roof rack and could separate from the roof rack. this recall only pertains to aftermarket rear shell roof racks and has no relation to any original equipment installed on jeep wrangler vehicles by daimlerchrysler.

Corrective Action

should this occur, the cockpit could cause injury by striking persons outside the vehicle or could become a distraction or an obstacle to other drivers, possibly resulting in a vehicle crash.

Recall Notes

bestop will notify its customers and provide a repair kit and installation instructions free of charge. owner notification began june 16, 2004. owners who do not receive the free remedy within a reasonable time should contact bestop customer service department at (800) 845-3567.

1993 Jeep Wrangler

Component

Fuel System, Gasoline:Delivery:Fuel Pump

Consequence of Defect

vehicle description: multipurpose passenger vehicles equipped with plastic fuel tanks. the fuel tank sending unit gasket can crack causing fuel and fuel vapor leaks.

Corrective Action

fuel and fuel vapor leaked from the fuel tank can result in fire when exposed to a source of ignition.

Recall Notes

replace the fuel tank sending unit gasket.

1993 Jeep Wrangler

Component

Exterior Lighting

Consequence of Defect

certain pro-a motors corner lamps, turn signals, and headlights sold as replacement lamps for use on certain passenger vehicles listed above. some combination lamps that are not equipped with amber side reflectors fail to conform to federal motor vehicle safety standard no. 108, lamps, reflective devices, and associated equipment.

Corrective Action

without the amber reflectors, the vehicle will be poorly illuminated, possibly resulting in a vehicle crash without warning.

Recall Notes

pro-a motors will notify owners and offer to repurchase the lamps. the recall began on april 3, 2006. owners may contact pro-a motors at 323-838-2988.

1993 Jeep Wrangler

Component

Electrical System:Ignition:Switch

Consequence of Defect

salt corrosion products between the starter solenoid wire and the adjacent battery feed in the bulkhead connector may short these connections, causing the circuit to bypass the ignition key control of the starter motor solenoid. the car can start without the starter sequence being initiated by the ignition key in the ignition lock.

Corrective Action

the unintended start of a vehicle with a manualtransmission left in a drive gear can result in a runaway vehicle.

Recall Notes

the starter solenoid wiring will be separated from the battery feed wire by relocating it within the bulkhead connector on affected vehicles.

1992 Jeep Wrangler

Component

Parking Brake:Conventional

Consequence of Defect

on certain sport utility vehicles equipped with manual transmissions, the parking brake can self-release without warning.

Corrective Action

this could allow the vehicle to roll away, increasing the risk of a crash.

Recall Notes

dealers will install a parking brake assembly with a stronger pawl return spring. owner notificaton began september 30, 2002. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact daimlerchrysler at 1-800-853-1403.

1992 Jeep Wrangler

Component

Equipment

Consequence of Defect

bestop aftermarket rear shell roof racks,manufactured between april 27 and may 20, 2004, designed for use with the bestop hardtop made for the 1986-1995 and 1997-2003 jeep wrangler. the cockpit cover may not stay latched to the roof rack because the latch bracket mispositions the rotary latch to the cockpit cover. as a result, the cockpit cover may not stay latched to the roof rack and could separate from the roof rack. this recall only pertains to aftermarket rear shell roof racks and has no relation to any original equipment installed on jeep wrangler vehicles by daimlerchrysler.

Corrective Action

should this occur, the cockpit could cause injury by striking persons outside the vehicle or could become a distraction or an obstacle to other drivers, possibly resulting in a vehicle crash.

Recall Notes

bestop will notify its customers and provide a repair kit and installation instructions free of charge. owner notification began june 16, 2004. owners who do not receive the free remedy within a reasonable time should contact bestop customer service department at (800) 845-3567.

1992 Jeep Wrangler

Component

Fuel System, Gasoline:Delivery:Fuel Pump

Consequence of Defect

vehicle description: multipurpose passenger vehicles equipped with plastic fuel tanks. the fuel tank sending unit gasket can crack causing fuel and fuel vapor leaks.

Corrective Action

fuel and fuel vapor leaked from the fuel tank can result in fire when exposed to a source of ignition.

Recall Notes

replace the fuel tank sending unit gasket.

1992 Jeep Wrangler

Component

Exterior Lighting

Consequence of Defect

certain pro-a motors corner lamps, turn signals, and headlights sold as replacement lamps for use on certain passenger vehicles listed above. some combination lamps that are not equipped with amber side reflectors fail to conform to federal motor vehicle safety standard no. 108, lamps, reflective devices, and associated equipment.

Corrective Action

without the amber reflectors, the vehicle will be poorly illuminated, possibly resulting in a vehicle crash without warning.

Recall Notes

pro-a motors will notify owners and offer to repurchase the lamps. the recall began on april 3, 2006. owners may contact pro-a motors at 323-838-2988.

1992 Jeep Wrangler

Component

Service Brakes, Hydraulic:Foundation Components:Hoses, Lines/Piping, And Fittings

Consequence of Defect

on 1987 through early 1990 models, both front brake hoses can wear due to direct contact with the wheel opening splash shields. on the late 1990 through 1992 models, periodic rubbing contact of the left front brake hose can occur due to movement of the splash shield in certain vehicle operating conditions.

Corrective Action

either condition can cause loss of front brake systemfunctions, resulting in increased stopping distances and an increased risk ofvehicle accident.

Recall Notes

the 1987 to 1990 model vehicles will have both splash shields replaced and both front brake hoses replaced as necessary. all affected late 1990 through 1992 model year vehicles will have additional fasteners installed to further secure the left side splash shield. also, the left front brake hose will be inspected and replaced as necessary.

1992 Jeep Wrangler

Component

Electrical System:Ignition:Switch

Consequence of Defect

salt corrosion products between the starter solenoid wire and the adjacent battery feed in the bulkhead connector may short these connections, causing the circuit to bypass the ignition key control of the starter motor solenoid. the car can start without the starter sequence being initiated by the ignition key in the ignition lock.

Corrective Action

the unintended start of a vehicle with a manualtransmission left in a drive gear can result in a runaway vehicle.

Recall Notes

the starter solenoid wiring will be separated from the battery feed wire by relocating it within the bulkhead connector on affected vehicles.

1991 Jeep Wrangler

Component

Parking Brake:Conventional

Consequence of Defect

on certain sport utility vehicles equipped with manual transmissions, the parking brake can self-release without warning.

Corrective Action

this could allow the vehicle to roll away, increasing the risk of a crash.

Recall Notes

dealers will install a parking brake assembly with a stronger pawl return spring. owner notificaton began september 30, 2002. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact daimlerchrysler at 1-800-853-1403.

1991 Jeep Wrangler

Component

Service Brakes, Hydraulic:Foundation Components:Disc:Rotor

Consequence of Defect

vehicle description: passenger and multi-purpose vehicles originally sold or currently registered in the states of connecticut, illinois, indiana, maine, maryland, massachusetts, michigan, new hampshire, new jersey, new york, ohio, pennsylvania, rhode island, vermont, or wisconsin, and the district of columbia. the front disc brake rotors can experience severe corrosion if operated for an extensive period in the "salt belt." if the rotors are not replaced, the corrosion can eventually compromise the structural integrity of the stamped steel center hub section of the rotor.

Corrective Action

the reduced strength can allow the cast iron wear surface to separate from the hub, reducing the brake effectiveness of the vehicle.

Recall Notes

dealers will replace these rotors with rotors that are coated with a corrosion protection.

1991 Jeep Wrangler

Component

Equipment

Consequence of Defect

bestop aftermarket rear shell roof racks,manufactured between april 27 and may 20, 2004, designed for use with the bestop hardtop made for the 1986-1995 and 1997-2003 jeep wrangler. the cockpit cover may not stay latched to the roof rack because the latch bracket mispositions the rotary latch to the cockpit cover. as a result, the cockpit cover may not stay latched to the roof rack and could separate from the roof rack. this recall only pertains to aftermarket rear shell roof racks and has no relation to any original equipment installed on jeep wrangler vehicles by daimlerchrysler.

Corrective Action

should this occur, the cockpit could cause injury by striking persons outside the vehicle or could become a distraction or an obstacle to other drivers, possibly resulting in a vehicle crash.

Recall Notes

bestop will notify its customers and provide a repair kit and installation instructions free of charge. owner notification began june 16, 2004. owners who do not receive the free remedy within a reasonable time should contact bestop customer service department at (800) 845-3567.

1991 Jeep Wrangler

Component

Fuel System, Gasoline:Delivery:Fuel Pump

Consequence of Defect

vehicle description: multipurpose passenger vehicles equipped with plastic fuel tanks. the fuel tank sending unit gasket can crack causing fuel and fuel vapor leaks.

Corrective Action

fuel and fuel vapor leaked from the fuel tank can result in fire when exposed to a source of ignition.

Recall Notes

replace the fuel tank sending unit gasket.

1991 Jeep Wrangler

Component

Exterior Lighting

Consequence of Defect

certain pro-a motors corner lamps, turn signals, and headlights sold as replacement lamps for use on certain passenger vehicles listed above. some combination lamps that are not equipped with amber side reflectors fail to conform to federal motor vehicle safety standard no. 108, lamps, reflective devices, and associated equipment.

Corrective Action

without the amber reflectors, the vehicle will be poorly illuminated, possibly resulting in a vehicle crash without warning.

Recall Notes

pro-a motors will notify owners and offer to repurchase the lamps. the recall began on april 3, 2006. owners may contact pro-a motors at 323-838-2988.

1991 Jeep Wrangler

Component

Service Brakes, Hydraulic:Foundation Components:Hoses, Lines/Piping, And Fittings

Consequence of Defect

on 1987 through early 1990 models, both front brake hoses can wear due to direct contact with the wheel opening splash shields. on the late 1990 through 1992 models, periodic rubbing contact of the left front brake hose can occur due to movement of the splash shield in certain vehicle operating conditions.

Corrective Action

either condition can cause loss of front brake systemfunctions, resulting in increased stopping distances and an increased risk ofvehicle accident.

Recall Notes

the 1987 to 1990 model vehicles will have both splash shields replaced and both front brake hoses replaced as necessary. all affected late 1990 through 1992 model year vehicles will have additional fasteners installed to further secure the left side splash shield. also, the left front brake hose will be inspected and replaced as necessary.

1991 Jeep Wrangler

Component

Equipment:Other:Labels

Consequence of Defect

certification label does not contain required tire and wheel information.

Corrective Action

vehicles would not comply with fmvss 120.

Recall Notes

install supplemental tire information labels adjacent to certification labels.

1991 Jeep Wrangler

Component

Electrical System:Ignition:Switch

Consequence of Defect

salt corrosion products between the starter solenoid wire and the adjacent battery feed in the bulkhead connector may short these connections, causing the circuit to bypass the ignition key control of the starter motor solenoid. the car can start without the starter sequence being initiated by the ignition key in the ignition lock.

Corrective Action

the unintended start of a vehicle with a manualtransmission left in a drive gear can result in a runaway vehicle.

Recall Notes

the starter solenoid wiring will be separated from the battery feed wire by relocating it within the bulkhead connector on affected vehicles.

1990 Jeep Wrangler

Component

Parking Brake:Conventional

Consequence of Defect

on certain sport utility vehicles equipped with manual transmissions, the parking brake can self-release without warning.

Corrective Action

this could allow the vehicle to roll away, increasing the risk of a crash.

Recall Notes

dealers will install a parking brake assembly with a stronger pawl return spring. owner notificaton began september 30, 2002. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact daimlerchrysler at 1-800-853-1403.

1990 Jeep Wrangler

Component

Service Brakes, Hydraulic:Foundation Components:Disc:Rotor

Consequence of Defect

vehicle description: passenger and multi-purpose vehicles originally sold or currently registered in the states of connecticut, illinois, indiana, maine, maryland, massachusetts, michigan, new hampshire, new jersey, new york, ohio, pennsylvania, rhode island, vermont, or wisconsin, and the district of columbia. the front disc brake rotors can experience severe corrosion if operated for an extensive period in the "salt belt." if the rotors are not replaced, the corrosion can eventually compromise the structural integrity of the stamped steel center hub section of the rotor.

Corrective Action

the reduced strength can allow the cast iron wear surface to separate from the hub, reducing the brake effectiveness of the vehicle.

Recall Notes

dealers will replace these rotors with rotors that are coated with a corrosion protection.

1990 Jeep Wrangler

Component

Equipment

Consequence of Defect

bestop aftermarket rear shell roof racks,manufactured between april 27 and may 20, 2004, designed for use with the bestop hardtop made for the 1986-1995 and 1997-2003 jeep wrangler. the cockpit cover may not stay latched to the roof rack because the latch bracket mispositions the rotary latch to the cockpit cover. as a result, the cockpit cover may not stay latched to the roof rack and could separate from the roof rack. this recall only pertains to aftermarket rear shell roof racks and has no relation to any original equipment installed on jeep wrangler vehicles by daimlerchrysler.

Corrective Action

should this occur, the cockpit could cause injury by striking persons outside the vehicle or could become a distraction or an obstacle to other drivers, possibly resulting in a vehicle crash.

Recall Notes

bestop will notify its customers and provide a repair kit and installation instructions free of charge. owner notification began june 16, 2004. owners who do not receive the free remedy within a reasonable time should contact bestop customer service department at (800) 845-3567.

1990 Jeep Wrangler

Component

Fuel System, Gasoline:Delivery:Fuel Pump

Consequence of Defect

vehicle description: multipurpose passenger vehicles equipped with plastic fuel tanks. the fuel tank sending unit gasket can crack causing fuel and fuel vapor leaks.

Corrective Action

fuel and fuel vapor leaked from the fuel tank can result in fire when exposed to a source of ignition.

Recall Notes

replace the fuel tank sending unit gasket.

1990 Jeep Wrangler

Component

Exterior Lighting

Consequence of Defect

certain pro-a motors corner lamps, turn signals, and headlights sold as replacement lamps for use on certain passenger vehicles listed above. some combination lamps that are not equipped with amber side reflectors fail to conform to federal motor vehicle safety standard no. 108, lamps, reflective devices, and associated equipment.

Corrective Action

without the amber reflectors, the vehicle will be poorly illuminated, possibly resulting in a vehicle crash without warning.

Recall Notes

pro-a motors will notify owners and offer to repurchase the lamps. the recall began on april 3, 2006. owners may contact pro-a motors at 323-838-2988.

1990 Jeep Wrangler

Component

Service Brakes, Hydraulic:Foundation Components:Hoses, Lines/Piping, And Fittings

Consequence of Defect

on 1987 through early 1990 models, both front brake hoses can wear due to direct contact with the wheel opening splash shields. on the late 1990 through 1992 models, periodic rubbing contact of the left front brake hose can occur due to movement of the splash shield in certain vehicle operating conditions.

Corrective Action

either condition can cause loss of front brake systemfunctions, resulting in increased stopping distances and an increased risk ofvehicle accident.

Recall Notes

the 1987 to 1990 model vehicles will have both splash shields replaced and both front brake hoses replaced as necessary. all affected late 1990 through 1992 model year vehicles will have additional fasteners installed to further secure the left side splash shield. also, the left front brake hose will be inspected and replaced as necessary.

1990 Jeep Wrangler

Component

Fuel System, Gasoline:Delivery:Fuel Pump

Consequence of Defect

certain federal-mogul aftermarket fuel pumps sold under the brand names of carter, accuflow, napa, truflow, parts depo, and parts master, shipped between august 2006 and july 2007 for use on the vehicles listed above. the fuel pump diaphragm in certain production runs may have been improperly installed or inadequately tested which may cause the fuel pump to leak.

Corrective Action

a leaking fuel pump could create a vehicle fire hazard.

Recall Notes

federal-mogul will notify owners and replace the defective fuel pumps free of charge. the recall is expected to begin during september 2007. owners can contact federal-mogul at 248-354-7700.

1989 Jeep Wrangler

Component

Fuel System, Gasoline:Storage

Consequence of Defect

in a rear impact collission, fuel tank may leak fuel in excess of amount allowed by fmvss 301 because of misbuilt fuel tank skid plates.

Corrective Action

in the presence of an ignition source, this could resultin a fire. vehicle would not comply with fmvss 301.

Recall Notes

install flange on fuel tank skid plate.

1989 Jeep Wrangler

Component

Visibility:Windshield Wiper/Washer:Linkages

Consequence of Defect

windshield frame metal may crack at the wiper arm pivot mountings due to metal stress during wiper operation.

Corrective Action

this can cause dislocation and binding of the wipersystem linkage which, in inclement weather, could affect driver visibility andresult in an accident.

Recall Notes

retrofit with a windshield frame reinforcement at the wiper pivot locations and install new redesigned linkage components to reduce stress at the pivot mountings.

1989 Jeep Wrangler

Component

Equipment

Consequence of Defect

bestop aftermarket rear shell roof racks,manufactured between april 27 and may 20, 2004, designed for use with the bestop hardtop made for the 1986-1995 and 1997-2003 jeep wrangler. the cockpit cover may not stay latched to the roof rack because the latch bracket mispositions the rotary latch to the cockpit cover. as a result, the cockpit cover may not stay latched to the roof rack and could separate from the roof rack. this recall only pertains to aftermarket rear shell roof racks and has no relation to any original equipment installed on jeep wrangler vehicles by daimlerchrysler.

Corrective Action

should this occur, the cockpit could cause injury by striking persons outside the vehicle or could become a distraction or an obstacle to other drivers, possibly resulting in a vehicle crash.

Recall Notes

bestop will notify its customers and provide a repair kit and installation instructions free of charge. owner notification began june 16, 2004. owners who do not receive the free remedy within a reasonable time should contact bestop customer service department at (800) 845-3567.

1989 Jeep Wrangler

Component

Fuel System, Gasoline:Delivery:Fuel Pump

Consequence of Defect

vehicle description: multipurpose passenger vehicles equipped with plastic fuel tanks. the fuel tank sending unit gasket can crack causing fuel and fuel vapor leaks.

Corrective Action

fuel and fuel vapor leaked from the fuel tank can result in fire when exposed to a source of ignition.

Recall Notes

replace the fuel tank sending unit gasket.

1989 Jeep Wrangler

Component

Exterior Lighting

Consequence of Defect

certain pro-a motors corner lamps, turn signals, and headlights sold as replacement lamps for use on certain passenger vehicles listed above. some combination lamps that are not equipped with amber side reflectors fail to conform to federal motor vehicle safety standard no. 108, lamps, reflective devices, and associated equipment.

Corrective Action

without the amber reflectors, the vehicle will be poorly illuminated, possibly resulting in a vehicle crash without warning.

Recall Notes

pro-a motors will notify owners and offer to repurchase the lamps. the recall began on april 3, 2006. owners may contact pro-a motors at 323-838-2988.

1989 Jeep Wrangler

Component

Service Brakes, Hydraulic:Foundation Components:Hoses, Lines/Piping, And Fittings

Consequence of Defect

on 1987 through early 1990 models, both front brake hoses can wear due to direct contact with the wheel opening splash shields. on the late 1990 through 1992 models, periodic rubbing contact of the left front brake hose can occur due to movement of the splash shield in certain vehicle operating conditions.

Corrective Action

either condition can cause loss of front brake systemfunctions, resulting in increased stopping distances and an increased risk ofvehicle accident.

Recall Notes

the 1987 to 1990 model vehicles will have both splash shields replaced and both front brake hoses replaced as necessary. all affected late 1990 through 1992 model year vehicles will have additional fasteners installed to further secure the left side splash shield. also, the left front brake hose will be inspected and replaced as necessary.

1989 Jeep Wrangler

Component

Fuel System, Gasoline:Delivery:Fuel Pump

Consequence of Defect

certain federal-mogul aftermarket fuel pumps sold under the brand names of carter, accuflow, napa, truflow, parts depo, and parts master, shipped between august 2006 and july 2007 for use on the vehicles listed above. the fuel pump diaphragm in certain production runs may have been improperly installed or inadequately tested which may cause the fuel pump to leak.

Corrective Action

a leaking fuel pump could create a vehicle fire hazard.

Recall Notes

federal-mogul will notify owners and replace the defective fuel pumps free of charge. the recall is expected to begin during september 2007. owners can contact federal-mogul at 248-354-7700.

1988 Jeep Wrangler

Component

Visibility:Windshield Wiper/Washer:Linkages

Consequence of Defect

windshield frame metal may crack at the wiper arm pivot mountings due to metal stress during wiper operation.

Corrective Action

this can cause dislocation and binding of the wipersystem linkage which, in inclement weather, could affect driver visibility andresult in an accident.

Recall Notes

retrofit with a windshield frame reinforcement at the wiper pivot locations and redesigned linkage components to reduce stress at the pivot mountings.

1988 Jeep Wrangler

Component

Equipment

Consequence of Defect

bestop aftermarket rear shell roof racks,manufactured between april 27 and may 20, 2004, designed for use with the bestop hardtop made for the 1986-1995 and 1997-2003 jeep wrangler. the cockpit cover may not stay latched to the roof rack because the latch bracket mispositions the rotary latch to the cockpit cover. as a result, the cockpit cover may not stay latched to the roof rack and could separate from the roof rack. this recall only pertains to aftermarket rear shell roof racks and has no relation to any original equipment installed on jeep wrangler vehicles by daimlerchrysler.

Corrective Action

should this occur, the cockpit could cause injury by striking persons outside the vehicle or could become a distraction or an obstacle to other drivers, possibly resulting in a vehicle crash.

Recall Notes

bestop will notify its customers and provide a repair kit and installation instructions free of charge. owner notification began june 16, 2004. owners who do not receive the free remedy within a reasonable time should contact bestop customer service department at (800) 845-3567.

1988 Jeep Wrangler

Component

Fuel System, Gasoline:Delivery:Fuel Pump

Consequence of Defect

vehicle description: multipurpose passenger vehicles equipped with plastic fuel tanks. the fuel tank sending unit gasket can crack causing fuel and fuel vapor leaks.

Corrective Action

fuel and fuel vapor leaked from the fuel tank can result in fire when exposed to a source of ignition.

Recall Notes

replace the fuel tank sending unit gasket.

1988 Jeep Wrangler

Component

Exterior Lighting

Consequence of Defect

certain pro-a motors corner lamps, turn signals, and headlights sold as replacement lamps for use on certain passenger vehicles listed above. some combination lamps that are not equipped with amber side reflectors fail to conform to federal motor vehicle safety standard no. 108, lamps, reflective devices, and associated equipment.

Corrective Action

without the amber reflectors, the vehicle will be poorly illuminated, possibly resulting in a vehicle crash without warning.

Recall Notes

pro-a motors will notify owners and offer to repurchase the lamps. the recall began on april 3, 2006. owners may contact pro-a motors at 323-838-2988.

1988 Jeep Wrangler

Component

Service Brakes, Hydraulic:Foundation Components:Hoses, Lines/Piping, And Fittings

Consequence of Defect

on 1987 through early 1990 models, both front brake hoses can wear due to direct contact with the wheel opening splash shields. on the late 1990 through 1992 models, periodic rubbing contact of the left front brake hose can occur due to movement of the splash shield in certain vehicle operating conditions.

Corrective Action

either condition can cause loss of front brake systemfunctions, resulting in increased stopping distances and an increased risk ofvehicle accident.

Recall Notes

the 1987 to 1990 model vehicles will have both splash shields replaced and both front brake hoses replaced as necessary. all affected late 1990 through 1992 model year vehicles will have additional fasteners installed to further secure the left side splash shield. also, the left front brake hose will be inspected and replaced as necessary.

1988 Jeep Wrangler

Component

Fuel System, Gasoline:Delivery:Fuel Pump

Consequence of Defect

certain federal-mogul aftermarket fuel pumps sold under the brand names of carter, accuflow, napa, truflow, parts depo, and parts master, shipped between august 2006 and july 2007 for use on the vehicles listed above. the fuel pump diaphragm in certain production runs may have been improperly installed or inadequately tested which may cause the fuel pump to leak.

Corrective Action

a leaking fuel pump could create a vehicle fire hazard.

Recall Notes

federal-mogul will notify owners and replace the defective fuel pumps free of charge. the recall is expected to begin during september 2007. owners can contact federal-mogul at 248-354-7700.

1987 Jeep Wrangler

Component

Wheels:Lugs/Nuts/Bolts

Consequence of Defect

the wheel lug nuts may have been improperly tightened. also, the steering shaft clamp bolts may not be properly tightened. consequence of defect: improperly tighten wheel lug nuts may cause the lugs to break and eventually result in the wheel falling off. improperly tighten steering shaft clamp bolt may cause complete loss of steering ability. either of these conditions could result in a loss of steering control and a crash could occur without prior warning.

Corrective Action

Recall Notes

properly tighten both wheel lug nuts and steering shaft clamp bolts.

1987 Jeep Wrangler

Component

Visibility:Windshield Wiper/Washer:Linkages

Consequence of Defect

windshield frame metal may crack at the wiper arm pivot mountings due to metal stress during wiper operation.

Corrective Action

this can cause dislocation and binding of the wipersystem linkage which, in inclement weather, could affect driver visibility andresult in an accident.

Recall Notes

retrofit with a windshield frame reinforcement at the wiper pivot locations and redesigned linkage components to reduce stress at the pivot mountings.

1987 Jeep Wrangler

Component

Vehicle Speed Control

Consequence of Defect

cruise control module could have inconsistent cruise control operation.

Corrective Action

inconsistent cruise control operation could result inloss of control and an accident.

Recall Notes

replace module, as necessary.

1987 Jeep Wrangler

Component

Equipment

Consequence of Defect

bestop aftermarket rear shell roof racks,manufactured between april 27 and may 20, 2004, designed for use with the bestop hardtop made for the 1986-1995 and 1997-2003 jeep wrangler. the cockpit cover may not stay latched to the roof rack because the latch bracket mispositions the rotary latch to the cockpit cover. as a result, the cockpit cover may not stay latched to the roof rack and could separate from the roof rack. this recall only pertains to aftermarket rear shell roof racks and has no relation to any original equipment installed on jeep wrangler vehicles by daimlerchrysler.

Corrective Action

should this occur, the cockpit could cause injury by striking persons outside the vehicle or could become a distraction or an obstacle to other drivers, possibly resulting in a vehicle crash.

Recall Notes

bestop will notify its customers and provide a repair kit and installation instructions free of charge. owner notification began june 16, 2004. owners who do not receive the free remedy within a reasonable time should contact bestop customer service department at (800) 845-3567.

1987 Jeep Wrangler

Component

Fuel System, Gasoline:Delivery:Fuel Pump

Consequence of Defect

vehicle description: multipurpose passenger vehicles equipped with plastic fuel tanks. the fuel tank sending unit gasket can crack causing fuel and fuel vapor leaks.

Corrective Action

fuel and fuel vapor leaked from the fuel tank can result in fire when exposed to a source of ignition.

Recall Notes

replace the fuel tank sending unit gasket.

1987 Jeep Wrangler

Component

Exterior Lighting

Consequence of Defect

certain pro-a motors corner lamps, turn signals, and headlights sold as replacement lamps for use on certain passenger vehicles listed above. some combination lamps that are not equipped with amber side reflectors fail to conform to federal motor vehicle safety standard no. 108, lamps, reflective devices, and associated equipment.

Corrective Action

without the amber reflectors, the vehicle will be poorly illuminated, possibly resulting in a vehicle crash without warning.

Recall Notes

pro-a motors will notify owners and offer to repurchase the lamps. the recall began on april 3, 2006. owners may contact pro-a motors at 323-838-2988.

1987 Jeep Wrangler

Component

Service Brakes, Hydraulic:Foundation Components:Hoses, Lines/Piping, And Fittings

Consequence of Defect

on 1987 through early 1990 models, both front brake hoses can wear due to direct contact with the wheel opening splash shields. on the late 1990 through 1992 models, periodic rubbing contact of the left front brake hose can occur due to movement of the splash shield in certain vehicle operating conditions.

Corrective Action

either condition can cause loss of front brake systemfunctions, resulting in increased stopping distances and an increased risk ofvehicle accident.

Recall Notes

the 1987 to 1990 model vehicles will have both splash shields replaced and both front brake hoses replaced as necessary. all affected late 1990 through 1992 model year vehicles will have additional fasteners installed to further secure the left side splash shield. also, the left front brake hose will be inspected and replaced as necessary.

1987 Jeep Wrangler

Component

Fuel System, Gasoline:Delivery:Fuel Pump

Consequence of Defect

certain federal-mogul aftermarket fuel pumps sold under the brand names of carter, accuflow, napa, truflow, parts depo, and parts master, shipped between august 2006 and july 2007 for use on the vehicles listed above. the fuel pump diaphragm in certain production runs may have been improperly installed or inadequately tested which may cause the fuel pump to leak.

Corrective Action

a leaking fuel pump could create a vehicle fire hazard.

Recall Notes

federal-mogul will notify owners and replace the defective fuel pumps free of charge. the recall is expected to begin during september 2007. owners can contact federal-mogul at 248-354-7700.

1986 Jeep Wrangler

Component

Equipment

Consequence of Defect

bestop aftermarket rear shell roof racks,manufactured between april 27 and may 20, 2004, designed for use with the bestop hardtop made for the 1986-1995 and 1997-2003 jeep wrangler. the cockpit cover may not stay latched to the roof rack because the latch bracket mispositions the rotary latch to the cockpit cover. as a result, the cockpit cover may not stay latched to the roof rack and could separate from the roof rack. this recall only pertains to aftermarket rear shell roof racks and has no relation to any original equipment installed on jeep wrangler vehicles by daimlerchrysler.

Corrective Action

should this occur, the cockpit could cause injury by striking persons outside the vehicle or could become a distraction or an obstacle to other drivers, possibly resulting in a vehicle crash.

Recall Notes

bestop will notify its customers and provide a repair kit and installation instructions free of charge. owner notification began june 16, 2004. owners who do not receive the free remedy within a reasonable time should contact bestop customer service department at (800) 845-3567.