Lemon Law Center

Home > Isuzu

2004 Isuzu Rodeo

Component

Fuel System, Gasoline:Delivery:Fuel Pump

Consequence of Defect

certain sport utility vehicles that have been exposed to fuel contaminated with silicon may develop small pin holes in the fuel pump feed port. silicon has been identified in the fuel systems of affected vehicles and in certain fuel available in the region of tyler, texas. this recall will be launched for vehicles registered in texas and the four surrounding states: oklahoma, arkansas, new mexico and louisiana.

Corrective Action

a fuel leak could lead to a vehicle fire.

Recall Notes

for vehicles registered in the states identified above, dealers will provide a new cover over the existing feed port on the fuel pump or, if the existing feed port has already been damaged, dealers will install a new fuel pump that is equipped with the new cover. the new cover will be made of a different material. the recall began on november 25, 2005. owners may contact isuzu at 1-800-255-6727.

2003 Isuzu Rodeo

Component

Service Brakes, Hydraulic:Switches:Brake Warning

Consequence of Defect

certain sport utility vehicles fail to comply with the requirements of federal motor vehicle safety standard no. 101, øcontrols and displays.ø the brake warning lamp would not illuminate in the event of decreased brake fluid volume.

Corrective Action

Recall Notes

the diodes have been replaced. all vehicles have been repaired.

2003 Isuzu Rodeo

Component

Fuel System, Gasoline:Delivery:Fuel Pump

Consequence of Defect

certain sport utility vehicles that have been exposed to fuel contaminated with silicon may develop small pin holes in the fuel pump feed port. silicon has been identified in the fuel systems of affected vehicles and in certain fuel available in the region of tyler, texas. this recall will be launched for vehicles registered in texas and the four surrounding states: oklahoma, arkansas, new mexico and louisiana.

Corrective Action

a fuel leak could lead to a vehicle fire.

Recall Notes

for vehicles registered in the states identified above, dealers will provide a new cover over the existing feed port on the fuel pump or, if the existing feed port has already been damaged, dealers will install a new fuel pump that is equipped with the new cover. the new cover will be made of a different material. the recall began on november 25, 2005. owners may contact isuzu at 1-800-255-6727.

2002 Isuzu Rodeo

Component

Fuel System, Gasoline:Delivery:Fuel Pump

Consequence of Defect

certain sport utility vehicles that have been exposed to fuel contaminated with silicon may develop small pin holes in the fuel pump feed port. silicon has been identified in the fuel systems of affected vehicles and in certain fuel available in the region of tyler, texas. this recall will be launched for vehicles registered in texas and the four surrounding states: oklahoma, arkansas, new mexico and louisiana.

Corrective Action

a fuel leak could lead to a vehicle fire.

Recall Notes

for vehicles registered in the states identified above, dealers will provide a new cover over the existing feed port on the fuel pump or, if the existing feed port has already been damaged, dealers will install a new fuel pump that is equipped with the new cover. the new cover will be made of a different material. the recall began on november 25, 2005. owners may contact isuzu at 1-800-255-6727.

2001 Isuzu Rodeo

Component

Air Bags:Frontal

Consequence of Defect

vehicle description: certain sport utility vehicles were built with the inflators in the passenger side air bag modules having the wrong amount of generant.

Corrective Action

in the event of a crash that would trigger a passenger air bag deployment, too much generant can cause the inflator module to explode. if the air bag module explodes, metal and plastic debris could cause severe injury to vehicle occupants.

Recall Notes

dealers will replace the passenger side air bag unit.

2001 Isuzu Rodeo

Component

Air Bags:Frontal

Consequence of Defect

on certain sport utility vehicles, the passenger-side air bag inflator modules were manufactured and shipped without a necessary component known as a check valve pin.

Corrective Action

in the event of a crash, the air bag will not inflate properly or sufficiently resulting in an increased risk of injury to the seat occupant.

Recall Notes

dealers will replace the passenger side air bag. owner notification is expected to begin during august or september 2002. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact isuzu at 1-800-643-4070.

2001 Isuzu Rodeo

Component

Fuel System, Gasoline:Delivery:Hoses, Lines/Piping, And Fittings

Consequence of Defect

vehicle description: sport utility vehicles. during the manufacture of certain fuel return hoses, incorrect rubber material for the outer layer was used.

Corrective Action

the fuel return hose does not meet ozone-resistant specifications, and could ultimately crack, causing fuel leakage. fuel leakage in the presence of an ignition source could result in a fire.

Recall Notes

dealers will inspect the vehicle to determine if the vehicle was equipped with an incorrect hose. if it is incorrect, dealers will replace it.

2000 Isuzu Rodeo

Component

Engine And Engine Cooling:Engine

Consequence of Defect

this is not a safety recall in accordance with the safety act. however, it is deemed a safety improvement campaign by the agency. vehicle description: 1998-2000 rodeo (ue) and amigo (ua) models equipped with 2.2l 4-cylinder engines. the timing belt could break before the recommended scheduled maintenance.

Corrective Action

this condition could cause the engine to crank but will not start or the engine could stall while driving and will not restart.

Recall Notes

dealer will inspect the vehicle to determine the condition of the timing belt and tensioner. the dealer will replace the timing belt. depending on the condition or model of the timing belt tensioner, the tensioner may also be replaced. isuzu has decided to conduct a service campaign to replace the timing belt. owner notification began june 22, 2001. owners can contact isuzu at 1-800-643-4070, ext. 426, concerning this program.

2000 Isuzu Rodeo

Component

Air Bags:Frontal

Consequence of Defect

vehicle description: certain sport utility vehicles were built with the inflators in the passenger side air bag modules having the wrong amount of generant.

Corrective Action

in the event of a crash that would trigger a passenger air bag deployment, too much generant can cause the inflator module to explode. if the air bag module explodes, metal and plastic debris could cause severe injury to vehicle occupants.

Recall Notes

dealers will replace the passenger side air bag unit.

2000 Isuzu Rodeo

Component

Air Bags:Frontal

Consequence of Defect

on certain sport utility vehicles, the passenger-side air bag inflator modules were manufactured and shipped without a necessary component known as a check valve pin.

Corrective Action

in the event of a crash, the air bag will not inflate properly or sufficiently resulting in an increased risk of injury to the seat occupant.

Recall Notes

dealers will replace the passenger side air bag. owner notification is expected to begin during august or september 2002. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact isuzu at 1-800-643-4070.

1999 Isuzu Rodeo

Component

Engine And Engine Cooling:Engine

Consequence of Defect

this is not a safety recall in accordance with the safety act. however, it is deemed a safety improvement campaign by the agency. vehicle description: 1998-2000 rodeo (ue) and amigo (ua) models equipped with 2.2l 4-cylinder engines. the timing belt could break before the recommended scheduled maintenance.

Corrective Action

this condition could cause the engine to crank but will not start or the engine could stall while driving and will not restart.

Recall Notes

dealer will inspect the vehicle to determine the condition of the timing belt and tensioner. the dealer will replace the timing belt. depending on the condition or model of the timing belt tensioner, the tensioner may also be replaced. isuzu has decided to conduct a service campaign to replace the timing belt. owner notification began june 22, 2001. owners can contact isuzu at 1-800-643-4070, ext. 426, concerning this program.

1999 Isuzu Rodeo

Component

Suspension:Rear

Consequence of Defect

vehicle description: sport utility vehicles. paint was applied unevenly on the rear axles, resulting in insufficient paint hardness. should this occur on the surface that contacts the rear axle lower link bracket bolt head and/or nut, the nut may loosen.

Corrective Action

the bolt could detach fully, causing separation of the lower link from the rear axle, increasing the risk of loss of vehicle control.

Recall Notes

dealers will replace the rear axle lower link joint nut and bolt.

1999 Isuzu Rodeo

Component

Structure:Body

Consequence of Defect

vehicle description: sport utility vehicles. these vehicles fail to comply with the performance requirements of fmvss no. 201, "occupant protection in interior impact."

Corrective Action

in the event of a crash, personal injury could occur.

Recall Notes

dealers will modify the interior of your vehicle.

1999 Isuzu Rodeo

Component

Service Brakes, Hydraulic:Antilock

Consequence of Defect

on certain sport utility vehicles that are equipped with an anti-lock braking system (abs), the vehicles can experience extended stopping distances in certain types of braking events.

Corrective Action

extended stopping distance could result, increasing the risk of a crash.

Recall Notes

dealers will provide a replacement computer algorithm for the abs that is based on the algorithm used in isuzu's my 2000 and 2001 vehicles, which have not had the problem. this campaign will be conducted in phases, with the my 1998 2wd vehicles covered first, since they have experienced the most problems. owner notification began march 20, 2003. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact isuzu at 1-800-643-4070.

1998 Isuzu Rodeo

Component

Electrical System:Wiring:Front Underhood

Consequence of Defect

vehicle description: sport utility vehicles. a ground connection terminal was not properly crimped in the supplier's engine wiring harness manufacturing line. this improper crimping process can leave an impression on the terminal that will eventually cause a stress fracture. s

Corrective Action

if a terminal is fractured, the powertrain control module (pcm) can receive an erroneous signal indicating a high vehicle speed, thereby causing the pcm to cut the fuel, causing a 'no-start' condition, or a possible engine stall.

Recall Notes

dealers will replace the wiring harness on these vehicles.

1998 Isuzu Rodeo

Component

Engine And Engine Cooling:Engine

Consequence of Defect

this is not a safety recall in accordance with the safety act. however, it is deemed a safety improvement campaign by the agency. vehicle description: 1998-2000 rodeo (ue) and amigo (ua) models equipped with 2.2l 4-cylinder engines. the timing belt could break before the recommended scheduled maintenance.

Corrective Action

this condition could cause the engine to crank but will not start or the engine could stall while driving and will not restart.

Recall Notes

dealer will inspect the vehicle to determine the condition of the timing belt and tensioner. the dealer will replace the timing belt. depending on the condition or model of the timing belt tensioner, the tensioner may also be replaced. isuzu has decided to conduct a service campaign to replace the timing belt. owner notification began june 22, 2001. owners can contact isuzu at 1-800-643-4070, ext. 426, concerning this program.

1998 Isuzu Rodeo

Component

Suspension:Rear

Consequence of Defect

vehicle description: sport utility vehicles. paint was applied unevenly on the rear axles, resulting in insufficient paint hardness. should this occur on the surface that contacts the rear axle lower link bracket bolt head and/or nut, the nut may loosen.

Corrective Action

the bolt could detach fully, causing separation of the lower link from the rear axle, increasing the risk of loss of vehicle control.

Recall Notes

dealers will replace the rear axle lower link joint nut and bolt.

1998 Isuzu Rodeo

Component

Other

Consequence of Defect

vehicle description: multi-purpose passenger vehicles equipped with a driver's side optional equipment rubber floor mat. repeated movement of the driver's feet and actuation of the accelerator pedal can result in a shifting of the mat's position. this shifting can cause an interference with the accelerator pedal.

Corrective Action

this could cause a restriction of the pedal's return to the idle position, increasing the risk of a vehicle crash.

Recall Notes

isuzu is asking for the return of the floor mat set and will reimburse owners for the cost of the rubber floor mat set along with any return shipping costs.

1998 Isuzu Rodeo

Component

Service Brakes, Hydraulic:Antilock

Consequence of Defect

on certain sport utility vehicles that are equipped with an anti-lock braking system (abs), the vehicles can experience extended stopping distances in certain types of braking events.

Corrective Action

extended stopping distance could result, increasing the risk of a crash.

Recall Notes

dealers will provide a replacement computer algorithm for the abs that is based on the algorithm used in isuzu's my 2000 and 2001 vehicles, which have not had the problem. this campaign will be conducted in phases, with the my 1998 2wd vehicles covered first, since they have experienced the most problems. owner notification began march 20, 2003. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact isuzu at 1-800-643-4070.

1997 Isuzu Rodeo

Component

Exterior Lighting

Consequence of Defect

certain aj motorsport combination lamps sold as replacement lamps for use on the above listed passenger vehicles. combination lamps not equipped with amber side reflectors fail to conform with the requirements of federal motor vehicle safety standard no. 108, lamps, reflective devices, and associated equipment.

Corrective Action

lack of amber side reflectors in the lamps will decrease lighting visibility to other drivers and may possibly result in a vehicle crash.

Recall Notes

aj motorsport will notify owners and offer reimbursement for the lamps. the recall began on july 31, 2006. owners may contact aj motorsport at 626-618-2026.

1996 Isuzu Rodeo

Component

Exterior Lighting

Consequence of Defect

certain aj motorsport combination lamps sold as replacement lamps for use on the above listed passenger vehicles. combination lamps not equipped with amber side reflectors fail to conform with the requirements of federal motor vehicle safety standard no. 108, lamps, reflective devices, and associated equipment.

Corrective Action

lack of amber side reflectors in the lamps will decrease lighting visibility to other drivers and may possibly result in a vehicle crash.

Recall Notes

aj motorsport will notify owners and offer reimbursement for the lamps. the recall began on july 31, 2006. owners may contact aj motorsport at 626-618-2026.

1995 Isuzu Rodeo

Component

Electrical System:Alternator/Generator/Regulator

Consequence of Defect

an integrated circuit within the voltage regulator can contain manufacturing errors.

Corrective Action

this can cause excessive electrical charging of the vehicle's alternator, resulting in engine control malfunction, and/or eventual engine stall.

Recall Notes

dealers will replace the voltage regulator with a new regulator.

1995 Isuzu Rodeo

Component

Exterior Lighting

Consequence of Defect

certain aj motorsport combination lamps sold as replacement lamps for use on the above listed passenger vehicles. combination lamps not equipped with amber side reflectors fail to conform with the requirements of federal motor vehicle safety standard no. 108, lamps, reflective devices, and associated equipment.

Corrective Action

lack of amber side reflectors in the lamps will decrease lighting visibility to other drivers and may possibly result in a vehicle crash.

Recall Notes

aj motorsport will notify owners and offer reimbursement for the lamps. the recall began on july 31, 2006. owners may contact aj motorsport at 626-618-2026.

1994 Isuzu Rodeo

Component

Seat Belts:Front:Buckle Assembly

Consequence of Defect

on certain sport utility vehicles and pickup trucks, the latch plate used in the seat belt buckle was not manufactured according to design dimensions. if the seat belt tongue is inserted slowly at an angle into the buckle, there is a possibility of partial engagement.

Corrective Action

this condition can cause the seat belt tongue to come out of the buckle in the event of a collision or hard braking of the vehicle increasing the risk of personal injury to an occupant of the seat.

Recall Notes

dealers will inspect the buckle and, if necessary, replace the buckle assembly with a new buckle. owner notification is expected to begin during mid-december 2002. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact isuzu at 1-800-643-4070.

1994 Isuzu Rodeo

Component

Seat Belts:Front:Buckle Assembly

Consequence of Defect

the latch plate used in the seat belt buckle was not manufactured according to design dimensions. if the seat belt tongue is inserted slowly at an angle into the buckle, there is a possibility of partial engagement.

Corrective Action

this condition can cause the seat belt tongue to come out of the buckle in the event of a collision or hard braking of the vehicle increasing the risk of personal injury to an occupant of the seat.

Recall Notes

dealers will inspect the buckle and, if necessary, replace the buckle assembly with a new buckle.

1994 Isuzu Rodeo

Component

Electrical System:Alternator/Generator/Regulator

Consequence of Defect

an integrated circuit within the voltage regulator can contain manufacturing errors.

Corrective Action

this can cause excessive electrical charging of the vehicle's alternator, resulting in engine control malfunction, and/or eventual engine stall.

Recall Notes

dealers will replace the voltage regulator with a new regulator.

1994 Isuzu Rodeo

Component

Exterior Lighting

Consequence of Defect

certain aj motorsport combination lamps sold as replacement lamps for use on the above listed passenger vehicles. combination lamps not equipped with amber side reflectors fail to conform with the requirements of federal motor vehicle safety standard no. 108, lamps, reflective devices, and associated equipment.

Corrective Action

lack of amber side reflectors in the lamps will decrease lighting visibility to other drivers and may possibly result in a vehicle crash.

Recall Notes

aj motorsport will notify owners and offer reimbursement for the lamps. the recall began on july 31, 2006. owners may contact aj motorsport at 626-618-2026.

1994 Isuzu Rodeo

Component

Engine And Engine Cooling:Engine

Consequence of Defect

constant expansion and contraction of the cylinder head causes the camshaft seal end plug can become dislodged from the cylinder head. this allows oil to leak from the camshaft.

Corrective Action

this can cause engine damage and possible engine fire from oil leaking onto the hot exhaust system.

Recall Notes

dealers will install camshaft end seal plug retainer plates.

1993 Isuzu Rodeo

Component

Exterior Lighting

Consequence of Defect

certain aj motorsport combination lamps sold as replacement lamps for use on the above listed passenger vehicles. combination lamps not equipped with amber side reflectors fail to conform with the requirements of federal motor vehicle safety standard no. 108, lamps, reflective devices, and associated equipment.

Corrective Action

lack of amber side reflectors in the lamps will decrease lighting visibility to other drivers and may possibly result in a vehicle crash.

Recall Notes

aj motorsport will notify owners and offer reimbursement for the lamps. the recall began on july 31, 2006. owners may contact aj motorsport at 626-618-2026.

1993 Isuzu Rodeo

Component

Engine And Engine Cooling:Engine

Consequence of Defect

constant expansion and contraction of the cylinder head causes the camshaft seal end plug can become dislodged from the cylinder head. this allows oil to leak from the camshaft.

Corrective Action

this can cause engine damage and possible engine fire from oil leaking onto the hot exhaust system.

Recall Notes

dealers will install camshaft end seal plug retainer plates.

1992 Isuzu Rodeo

Component

Exterior Lighting

Consequence of Defect

certain aj motorsport combination lamps sold as replacement lamps for use on the above listed passenger vehicles. combination lamps not equipped with amber side reflectors fail to conform with the requirements of federal motor vehicle safety standard no. 108, lamps, reflective devices, and associated equipment.

Corrective Action

lack of amber side reflectors in the lamps will decrease lighting visibility to other drivers and may possibly result in a vehicle crash.

Recall Notes

aj motorsport will notify owners and offer reimbursement for the lamps. the recall began on july 31, 2006. owners may contact aj motorsport at 626-618-2026.

1991 Isuzu Rodeo

Component

Exterior Lighting

Consequence of Defect

certain aj motorsport combination lamps sold as replacement lamps for use on the above listed passenger vehicles. combination lamps not equipped with amber side reflectors fail to conform with the requirements of federal motor vehicle safety standard no. 108, lamps, reflective devices, and associated equipment.

Corrective Action

lack of amber side reflectors in the lamps will decrease lighting visibility to other drivers and may possibly result in a vehicle crash.

Recall Notes

aj motorsport will notify owners and offer reimbursement for the lamps. the recall began on july 31, 2006. owners may contact aj motorsport at 626-618-2026.

1991 Isuzu Rodeo

Component

Power Train:Automatic Transmission

Consequence of Defect

the transmission fluid level gauges (dip sticks) installed in these vehicles are not to designed specifications. the gauge indicates that transmission fluid should be added when it is at the correct level.

Corrective Action

adding more transmission fluid than required will causethe fluid to leak through the fluid level gauge tube onto the manifold as theengine temperature rises. this creates a potential for a fire.

Recall Notes

replace oil level gauge and notify owners to use only the specified amount of automatic transmission fluid.