Lemon Law Center

Home > Chrysler

2008 Chrysler Sebring

Component

Air Bags:Frontal

Consequence of Defect

on certain passenger vehicles, the front seat track position sensors utilized for the air bag system may not function properly.

Corrective Action

this could increase the risk of injury to front seat occupants during certain crash conditions.

Recall Notes

dealers will inspect the front seat track position sensors and replace them free of charge. the recallbegan on june 18, 2007. owners may contact daimlerchrysler at 1-800-853-1403.

2008 Chrysler Sebring

Component

Engine And Engine Cooling:Cooling System:Radiator Assembly

Consequence of Defect

on certain vehicles equipped with 2.4 liter engines, the engine coolant may be drawn into the left radiator cooling fan motor connector.

Corrective Action

this can cause an electrical short circuit and result in an engine compartment fire.

Recall Notes

dealers will inspect the connector for contamination or damage, install a wiring harness overlay, and replace the fan motor free or charge. the recall began on november 19, 2007. owners may contact daimlerchrysler at 1-800-853-1403.

2008 Chrysler Sebring

Component

Latches/Locks/Linkages:Doors:Latch

Consequence of Defect

on certain vehicles, the front door latch cable may become partially unseated from the interior release handle housing possibly causing the latch to stick in the unlatched position or the lock function to become inoperative.

Corrective Action

driving a vehicle with an unlatched door can result in an unbelted front seat occupant falling out of the vehicle or being ejected in a crash, causing increased risk of injury.

Recall Notes

dealers will add a secondary retention feature to both front doors. this action will supersede and expand a previous safety recall (please see 07v-104). the recall began on october 29, 2007. owners may contact chrysler at 1-800-853-1403.

2007 Chrysler Sebring

Component

Structure:Body:Hood

Consequence of Defect

on certain passenger vehicles, the hood latch striker may break and allow the hood to open while driving.

Corrective Action

if the hood opens while driving, a crash could occur without prior warning.

Recall Notes

dealers will replace the hood latch strikers free of charge. the recall began on november 27, 2006. owners may contact daimlerchrysler at 1-800-853-1403.

2007 Chrysler Sebring

Component

Service Brakes, Hydraulic:Antilock:Control Unit/Module

Consequence of Defect

on certain vehicles, the antilock brake system (abs) control module software may cause the rear brakes to lock up during certain braking conditions.

Corrective Action

this could result in a loss of vehicle control and cause a crash without warning.

Recall Notes

dealers will reprogram the abs electronic control unit. the recall began on february 19, 2007. owners may contact daimlerchrysler at 1-800-853-1403.

2007 Chrysler Sebring

Component

Visibility:Defroster/Defogger System

Consequence of Defect

on certain vehicles equipped with automatic temperature control (atc) only, the software programmed into the heating ventilation and air conditioning (hvac) module may cause the windshield defrosting and defogging functions to become inoperative.

Corrective Action

this can decrease the driver's visibility under certain driving conditions and result in a crash without warning.

Recall Notes

dealers will reprogram the hvac module. the recall began on january 2, 2007. owners may contact daimlerchrysler at 1-800-853-1403.

2007 Chrysler Sebring

Component

Air Bags:Frontal

Consequence of Defect

on certain passenger vehicles, the front seat track position sensors utilized for the air bag system may not function properly.

Corrective Action

this could increase the risk of injury to front seat occupants during certain crash conditions.

Recall Notes

dealers will inspect the front seat track position sensors and replace them free of charge. the recallbegan on june 18, 2007. owners may contact daimlerchrysler at 1-800-853-1403.

2007 Chrysler Sebring

Component

Engine And Engine Cooling:Cooling System:Radiator Assembly

Consequence of Defect

on certain vehicles equipped with 2.4 liter engines, the engine coolant may be drawn into the left radiator cooling fan motor connector.

Corrective Action

this can cause an electrical short circuit and result in an engine compartment fire.

Recall Notes

dealers will inspect the connector for contamination or damage, install a wiring harness overlay, and replace the fan motor free or charge. the recall began on november 19, 2007. owners may contact daimlerchrysler at 1-800-853-1403.

2007 Chrysler Sebring

Component

Latches/Locks/Linkages:Doors:Latch

Consequence of Defect

on certain vehicles, the front door latch cable may become partially unseated from the interior release handle housing possibly causing the latch to stick in the unlatched position or the lock function to become inoperative.

Corrective Action

driving a vehicle with an unlatched door can result in an unbelted front seat occupant falling out of the vehicle or being ejected in a crash, causing increased risk of injury.

Recall Notes

dealers will add a secondary retention feature to both front doors. this action will supersede and expand a previous safety recall (please see 07v-104). the recall began on october 29, 2007. owners may contact chrysler at 1-800-853-1403.

2006 Chrysler Sebring

Component

Service Brakes, Hydraulic:Foundation Components:Master Cylinder

Consequence of Defect

certain cardone master cylinders with date codes lower than dca7078 sold as replacement equipment for use on the vehicles listed above. the seal on master cylinder can fail and leak brake fluid.

Corrective Action

loss of brake fluid can result in poor braking performance, possibly resulting in a vehicle crash.

Recall Notes

cardone will notify owners and offer to repurchase any defective master cylinders. the recall began during april 2007. owners can contact cardone at 1-800-777-4780.

2005 Chrysler Sebring

Component

Seat Belts:Rear

Consequence of Defect

on certain sedans, the left and right rear outboard retractor and turning loop bolts on the seat belts may not have been properly tightened.

Corrective Action

in the event of a crash, the seat occupant may not be properly restrained, increasing the risk of injury.

Recall Notes

dealers will inspect and tighten the affected fasteners. the recall began on november 15, 2004. owners should contact daimlerchrysler at 1-800-853-1403.

2005 Chrysler Sebring

Component

Service Brakes, Hydraulic:Foundation Components:Master Cylinder

Consequence of Defect

certain cardone master cylinders with date codes lower than dca7078 sold as replacement equipment for use on the vehicles listed above. the seal on master cylinder can fail and leak brake fluid.

Corrective Action

loss of brake fluid can result in poor braking performance, possibly resulting in a vehicle crash.

Recall Notes

cardone will notify owners and offer to repurchase any defective master cylinders. the recall began during april 2007. owners can contact cardone at 1-800-777-4780.

2005 Chrysler Sebring

Component

Steering:Linkages:Knuckle:Spindle:Arm

Consequence of Defect

on certain sedans and convertible model vehicles, the right steering knuckle may have been damaged during the component manufacturing process.

Corrective Action

this could cause the steering knuckle to crack and separate from the upper control arm, which could result in a crash.

Recall Notes

dealers will inspect and replace the right steering knuckle. the recall began on december 27, 2004. owners should contact daimlerchrysler at 1-800-853-1403.

2004 Chrysler Sebring

Component

Service Brakes, Hydraulic:Foundation Components:Master Cylinder

Consequence of Defect

certain cardone master cylinders with date codes lower than dca7078 sold as replacement equipment for use on the vehicles listed above. the seal on master cylinder can fail and leak brake fluid.

Corrective Action

loss of brake fluid can result in poor braking performance, possibly resulting in a vehicle crash.

Recall Notes

cardone will notify owners and offer to repurchase any defective master cylinders. the recall began during april 2007. owners can contact cardone at 1-800-777-4780.

2004 Chrysler Sebring

Component

Fuel System, Gasoline:Delivery:Hoses, Lines/Piping, And Fittings

Consequence of Defect

on certain 2-door passenger vehicles, the fuel return line hose fitting on the electric fuel pump may be improperly molded.

Corrective Action

breakage could result in a leakage of fuel and in the presence of an ignition source, it could result a fire.

Recall Notes

dealers will replace the fuel pump. the recall will begin on august 9, 2004. owners should contact daimlerchrysler at 1-800-853-1403.

2004 Chrysler Sebring

Component

Fuel System, Gasoline:Delivery:Fuel Pump

Consequence of Defect

on certain passenger vehicles, the fuel return line hose fitting on the electric fuel pump may be restricted, causing excessive fuel pressure to build up in the fuel injection system. excessive fuel pressure may result in a leak in the fuel return hose.

Corrective Action

fuel leakage in the presence of an ignition source could result in a fire.

Recall Notes

dealers will inspect the fuel pump pressure. those vehicles exhibiting higher than normal fuel pump pressure will receive fuel pump modifications. owner notification began on december 15, 2003. owners should contact daimlerchrysler at 1-800-992-1997.

2004 Chrysler Sebring

Component

Seat Belts:Rear

Consequence of Defect

on certain convertible model vehicles, the left hand rear seat belt retractor bolt may not have been properly tightened.

Corrective Action

this may result in the rear seat occupant being improperly restrained in a crash.

Recall Notes

dealers will tighten the left side rear seat belt retractor bolt to the proper specification. owner notification began on july 19, 2004. owners can contact daimlerchrysler at 1-800-853-1403.

2003 Chrysler Sebring

Component

Service Brakes, Hydraulic:Foundation Components:Master Cylinder

Consequence of Defect

certain cardone master cylinders with date codes lower than dca7078 sold as replacement equipment for use on the vehicles listed above. the seal on master cylinder can fail and leak brake fluid.

Corrective Action

loss of brake fluid can result in poor braking performance, possibly resulting in a vehicle crash.

Recall Notes

cardone will notify owners and offer to repurchase any defective master cylinders. the recall began during april 2007. owners can contact cardone at 1-800-777-4780.

2003 Chrysler Sebring

Component

Fuel System, Gasoline:Delivery:Fuel Pump

Consequence of Defect

on certain passenger vehicles, the fuel return line hose fitting on the electric fuel pump may be restricted, causing excessive fuel pressure to build up in the fuel injection system. excessive fuel pressure may result in a leak in the fuel return hose.

Corrective Action

fuel leakage in the presence of an ignition source could result in a fire.

Recall Notes

dealers will inspect the fuel pump pressure. those vehicles exhibiting higher than normal fuel pump pressure will receive fuel pump modifications. owner notification began on december 15, 2003. owners should contact daimlerchrysler at 1-800-992-1997.

2002 Chrysler Sebring

Component

Service Brakes, Hydraulic:Foundation Components:Master Cylinder

Consequence of Defect

certain cardone master cylinders with date codes lower than dca7078 sold as replacement equipment for use on the vehicles listed above. the seal on master cylinder can fail and leak brake fluid.

Corrective Action

loss of brake fluid can result in poor braking performance, possibly resulting in a vehicle crash.

Recall Notes

cardone will notify owners and offer to repurchase any defective master cylinders. the recall began during april 2007. owners can contact cardone at 1-800-777-4780.

2001 Chrysler Sebring

Component

Fuel System, Gasoline:Delivery:Hoses, Lines/Piping, And Fittings

Consequence of Defect

vehicle description: passenger vehicles. the outer layer only of this 3-layer fuel return hose does not contain the desired ozone protection due to a processing error.

Corrective Action

this hose is considered to be inadequate.

Recall Notes

dealers will replace the fuel return hose.

2001 Chrysler Sebring

Component

Engine And Engine Cooling:Engine

Consequence of Defect

vehicle description: passenger vehicles. the harness for the crankshaft position sensor could come in contact with a new protective shield causing a grounded circuit.

Corrective Action

prolonged wiring harness contact with the heat shield will cause the wiring insulation to wear and eventually to ground out. this could cause the engine to die-out, increasing the risk of a crash.

Recall Notes

dealers will re-route the crankshaft position sensor harness.

2001 Chrysler Sebring

Component

Structure: Frame And Members:Underbody Shields

Consequence of Defect

vehicle description: passenger vehicles. through degradation of the bond between the silencer pad and a sheet metal panel (quarter inner upper), the pad may fall onto the map light located in the rear seating area near the c-pillar trim panel (lh and rh). this contact could cause the pad to melt, creating a hot smell and/or smoke during long periods of illumination.

Corrective Action

smoke inhalation could be harmful to vehicle occupants.

Recall Notes

dealers will remove the insulation pad from behind both rear map lights.

2001 Chrysler Sebring

Component

Power Train:Automatic Transmission:Cooling Unit And Lines

Consequence of Defect

vehicle description: passenger vehicles equipped with automatic transmissions. a hose manufacturing process allowed the reinforcement yard to breach the inner layer of some automatic transmission hoses weakening the inner wall which could result in leakage of the automatic transmission fluid.

Corrective Action

fluid leakage from the cooler hoses can cause transaxle driveability problems and smoke if the oil contacts the front exhaust pipe.

Recall Notes

dealers will replace the transaxle oil cooler hoses. owner notification began april 9, 2001. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact daimlerchrysler at 1-800-853-1403.

2001 Chrysler Sebring

Component

Service Brakes, Hydraulic:Foundation Components:Master Cylinder

Consequence of Defect

certain cardone master cylinders with date codes lower than dca7078 sold as replacement equipment for use on the vehicles listed above. the seal on master cylinder can fail and leak brake fluid.

Corrective Action

loss of brake fluid can result in poor braking performance, possibly resulting in a vehicle crash.

Recall Notes

cardone will notify owners and offer to repurchase any defective master cylinders. the recall began during april 2007. owners can contact cardone at 1-800-777-4780.

2001 Chrysler Sebring

Component

Air Bags:Frontal

Consequence of Defect

vehicle description: passenger vehicles. passenger air bags were built with suspect aluminum extrusion sections which may not retain the air bag door during an air bag deployment event.

Corrective Action

a separated air bag door could injure a vehicle occupant.

Recall Notes

dealers will replace the passenger side air bag.

2001 Chrysler Sebring

Component

Seats

Consequence of Defect

vehicle description: passenger vehicles. a number of incorrect driver side seat mounting bolts were installed into vehicles.

Corrective Action

in the event of a crash, the bolts may not properly secure the seat and could cause increased injury to the driver of the vehicle.

Recall Notes

dealers will inspect the seat mounting bolts and then replace the bolts if necessary. owner notification began february 5, 2001. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact daimlerchrysler at 1-800-853-1403.

2001 Chrysler Sebring

Component

Child Seat

Consequence of Defect

vehicle description: certain passenger vehicles, pickup trucks and sport utility vehicles fail to comply with the requirements of fmvss no. 225, "child restraint anchorage systems." some of the owner's manuals for these vehicles are missing instructions that provide a step-by-step procedure, including diagrams, for properly attaching a child restraint system's tether strap to the tether anchorage.

Corrective Action

in the event of a crash, the child seat may not be properly attached increasing the risk of injury to the child.

Recall Notes

owners will be provided with an addendum to the owner's manuals.

2000 Chrysler Sebring

Component

Fuel System, Gasoline:Delivery:Fuel Pump

Consequence of Defect

certain airtex fuel pump module assemblies, p/n e7081h, sold for use as replacement equipment for the vehicles listed above. the wall of the flared fitting of the fuel pump is not thick enough to prevent the mating threaded fittings from bottoming out before an adequate seal is achieved. this condition may result in leakage of fuel at the connection of the vehicle fuel line and the fuel pump module assembly.

Corrective Action

in the presence of an ignition source, a fuel leak could result in a fire.

Recall Notes

airtex will notify owners and replace the fuel pumps free of charge. the recall is expected to begin during july 2007. owners can contact airtex automotive at 800-880-3056.

2000 Chrysler Sebring

Component

Exterior Lighting

Consequence of Defect

certain tradesonic combination lamps sold as replacement lamps for use on the above listed passenger vehicles. combination lamps not equipped with amber side reflectors fail to conform with the requirements of federal motor vehicle safety standard no. 108, lamps, reflective devices, and associated equipment.

Corrective Action

lack of amber side reflectors in the lamps will decrease lighting visibility to other drivers and may possibly result in a vehicle crash.

Recall Notes

tradesonic will notify owners and replace the lamps free of charge. the recall is expected to begin during july 2006. owners may contact tradesonic at 626-934-8884.

2000 Chrysler Sebring

Component

Suspension:Front:Control Arm:Lower Ball Joint

Consequence of Defect

vehicle description: passenger vehicles. if the rubber boots on the lower lateral arm ball joints of the front suspension were damaged during assembly, dirt and water can intrude. also, mmc has added the potential of leaking moisture, which can cause the ball stud to corrode.

Corrective Action

this condition could cause the lower lateral arm ball joint to separate, increasing the risk of a vehicle crash. this campaign supercedes mmc's previous safety recall campaign, see 99v-066.

Recall Notes

dealers will inspect the lower lateral arm ball joint for wear. ball joints that exhibit wear beyond the established tolerance will be replaced with newly designed lateral arm ball joints. ball joints that are within the established tolerance will be cleaned and a special sealant will be applied to prevent intrusion of moisture.

2000 Chrysler Sebring

Component

Fuel System, Gasoline:Delivery:Fuel Pump

Consequence of Defect

certain tigas fuel pump modules manufactured between june 1 and september 24, 2006, sold under various brand names and p/nos. these fuel pump modules are sold as aftermarket for use in certain daimlerchrysler vehicles listed above. silicone material used in manufacture of the flapper valve was out-of-specification, leading to excess swell of the flapper valve restricting the flow of fuel to the fuel pump module.

Corrective Action

fuel restriction could result in loss of power and/or engine stall, possibly resulting in a vehicle crash.

Recall Notes

ti automotive will notify owners and replace the defective fuel pump modules free of charge. the recall began on october 6, 2006. owners may contact ti automotive toll-free at 1-866-867-3759.

1999 Chrysler Sebring

Component

Fuel System, Gasoline:Delivery:Fuel Pump

Consequence of Defect

certain airtex fuel pump modules, p/nos. e7089m, e7094m, e7113m, and e7129m, manufactured between june 1 and september 24, 2006. these fuel pump modules were sold as aftermarket for use in certain daimlerchrysler vehicles listed above. silicone material used in manufacture of the flapper valve was out-of-specification, leading to excess swell of the flapper valve restricting the flow of fuel to the fuel pump module.

Corrective Action

fuel restriction could result in loss of power and/or engine stall, possibly resulting in a vehicle crash.

Recall Notes

airtex will notify owners and replace the defective fuel pump modules free of charge. the recall began on october 18, 2006. owners may contact airtex toll-free at 1-866-867-3759.

1999 Chrysler Sebring

Component

Fuel System, Gasoline:Delivery:Fuel Pump

Consequence of Defect

certain airtex fuel pump module assemblies, p/n e7081h, sold for use as replacement equipment for the vehicles listed above. the wall of the flared fitting of the fuel pump is not thick enough to prevent the mating threaded fittings from bottoming out before an adequate seal is achieved. this condition may result in leakage of fuel at the connection of the vehicle fuel line and the fuel pump module assembly.

Corrective Action

in the presence of an ignition source, a fuel leak could result in a fire.

Recall Notes

airtex will notify owners and replace the fuel pumps free of charge. the recall is expected to begin during july 2007. owners can contact airtex automotive at 800-880-3056.

1999 Chrysler Sebring

Component

Exterior Lighting

Consequence of Defect

certain tradesonic combination lamps sold as replacement lamps for use on the above listed passenger vehicles. combination lamps not equipped with amber side reflectors fail to conform with the requirements of federal motor vehicle safety standard no. 108, lamps, reflective devices, and associated equipment.

Corrective Action

lack of amber side reflectors in the lamps will decrease lighting visibility to other drivers and may possibly result in a vehicle crash.

Recall Notes

tradesonic will notify owners and replace the lamps free of charge. the recall is expected to begin during july 2006. owners may contact tradesonic at 626-934-8884.

1999 Chrysler Sebring

Component

Suspension:Front:Control Arm:Lower Ball Joint

Consequence of Defect

vehicle description: passenger vehicles. if the rubber boots on the lower lateral arm ball joints of the front suspension were damaged during assembly, dirt and water can intrude. also, mmc has added the potential of leaking moisture, which can cause the ball stud to corrode.

Corrective Action

this condition could cause the lower lateral arm ball joint to separate, increasing the risk of a vehicle crash. this campaign supercedes mmc's previous safety recall campaign, see 99v-066.

Recall Notes

dealers will inspect the lower lateral arm ball joint for wear. ball joints that exhibit wear beyond the established tolerance will be replaced with newly designed lateral arm ball joints. ball joints that are within the established tolerance will be cleaned and a special sealant will be applied to prevent intrusion of moisture.

1999 Chrysler Sebring

Component

Structure:Body:Roof And Pillars

Consequence of Defect

this is not a safety recall in accordance with the safety act. however, it is deemed a safety improvement campaign by the agency. vehicle description: passenger vehicles. if the convertible top cover is not installed correctly, it can separate unexpectedly from the vehicle while driving.

Corrective Action

if the cover separates while driving, it could distract the driver increasing the risk of a crash.

Recall Notes

owners will receive an improved convertible top cover instruction label and installation instructions.

1999 Chrysler Sebring

Component

Steering:Wheel And Handle Bar

Consequence of Defect

this is not a safety recall in accordance with the safety act. however, it is deemed a safety improvement campaign by the agency. vehicle description: 1998-1999 chrysler sebring jxi limited convertibles. the steering column intermediate shaft coupler pinch bolt retaining pin could snag and/or fray the edge of the driver's side floor mat.

Corrective Action

this could interfere with the steering control of the vehicle.

Recall Notes

dealer will replace the steering column intermediate shaft coupler pinch bolt and retaining pin. in addition, the front floor mats will be replaced.

1999 Chrysler Sebring

Component

Fuel System, Gasoline:Delivery:Fuel Pump

Consequence of Defect

certain tigas fuel pump modules manufactured between june 1 and september 24, 2006, sold under various brand names and p/nos. these fuel pump modules are sold as aftermarket for use in certain daimlerchrysler vehicles listed above. silicone material used in manufacture of the flapper valve was out-of-specification, leading to excess swell of the flapper valve restricting the flow of fuel to the fuel pump module.

Corrective Action

fuel restriction could result in loss of power and/or engine stall, possibly resulting in a vehicle crash.

Recall Notes

ti automotive will notify owners and replace the defective fuel pump modules free of charge. the recall began on october 6, 2006. owners may contact ti automotive toll-free at 1-866-867-3759.

1998 Chrysler Sebring

Component

Fuel System, Gasoline:Delivery:Fuel Pump

Consequence of Defect

certain airtex fuel pump modules, p/nos. e7089m, e7094m, e7113m, and e7129m, manufactured between june 1 and september 24, 2006. these fuel pump modules were sold as aftermarket for use in certain daimlerchrysler vehicles listed above. silicone material used in manufacture of the flapper valve was out-of-specification, leading to excess swell of the flapper valve restricting the flow of fuel to the fuel pump module.

Corrective Action

fuel restriction could result in loss of power and/or engine stall, possibly resulting in a vehicle crash.

Recall Notes

airtex will notify owners and replace the defective fuel pump modules free of charge. the recall began on october 18, 2006. owners may contact airtex toll-free at 1-866-867-3759.

1998 Chrysler Sebring

Component

Fuel System, Gasoline:Delivery:Fuel Pump

Consequence of Defect

certain airtex fuel pump module assemblies, p/n e7081h, sold for use as replacement equipment for the vehicles listed above. the wall of the flared fitting of the fuel pump is not thick enough to prevent the mating threaded fittings from bottoming out before an adequate seal is achieved. this condition may result in leakage of fuel at the connection of the vehicle fuel line and the fuel pump module assembly.

Corrective Action

in the presence of an ignition source, a fuel leak could result in a fire.

Recall Notes

airtex will notify owners and replace the fuel pumps free of charge. the recall is expected to begin during july 2007. owners can contact airtex automotive at 800-880-3056.

1998 Chrysler Sebring

Component

Exterior Lighting

Consequence of Defect

certain tradesonic combination lamps sold as replacement lamps for use on the above listed passenger vehicles. combination lamps not equipped with amber side reflectors fail to conform with the requirements of federal motor vehicle safety standard no. 108, lamps, reflective devices, and associated equipment.

Corrective Action

lack of amber side reflectors in the lamps will decrease lighting visibility to other drivers and may possibly result in a vehicle crash.

Recall Notes

tradesonic will notify owners and replace the lamps free of charge. the recall is expected to begin during july 2006. owners may contact tradesonic at 626-934-8884.

1998 Chrysler Sebring

Component

Suspension:Front:Control Arm:Lower Ball Joint

Consequence of Defect

vehicle description: passenger vehicles. if the rubber boots on the lower lateral arm ball joints of the front suspension were damaged during assembly, dirt and water can intrude. also, mmc has added the potential of leaking moisture, which can cause the ball stud to corrode.

Corrective Action

this condition could cause the lower lateral arm ball joint to separate, increasing the risk of a vehicle crash. this campaign supercedes mmc's previous safety recall campaign, see 99v-066.

Recall Notes

dealers will inspect the lower lateral arm ball joint for wear. ball joints that exhibit wear beyond the established tolerance will be replaced with newly designed lateral arm ball joints. ball joints that are within the established tolerance will be cleaned and a special sealant will be applied to prevent intrusion of moisture.

1998 Chrysler Sebring

Component

Vehicle Speed Control

Consequence of Defect

vehicle description: passenger vehicles. the dash panel pad can shift interferring with the throttle cable control.

Corrective Action

the throttle cable control would not return to idle increasing the risk of a vehicle crash.

Recall Notes

dealers will remove a portion of the dash panel pad so it cannot interfere with the throttle cable control.

1998 Chrysler Sebring

Component

Structure:Body:Roof And Pillars

Consequence of Defect

this is not a safety recall in accordance with the safety act. however, it is deemed a safety improvement campaign by the agency. vehicle description: passenger vehicles. if the convertible top cover is not installed correctly, it can separate unexpectedly from the vehicle while driving.

Corrective Action

if the cover separates while driving, it could distract the driver increasing the risk of a crash.

Recall Notes

owners will receive an improved convertible top cover instruction label and installation instructions.

1998 Chrysler Sebring

Component

Power Train:Automatic Transmission:Park/Neutral Start Switch

Consequence of Defect

vehicle description: passenger vehicles equipped with automatic transmissions. the adjustment of the cable connecting the console shifter mechanism to the ignition key can cause a trapped key condition which can result in a low force required to depress the shift button. a combination of applying a mis-adjusted release button with a low force attempt to shift out of park with the key in the locked position, can break the connecting pin in the shifter.

Corrective Action

if this happens, the "ignition-park" interlock system will be nonfunctional.

Recall Notes

dealers will inspect for proper operation of the system. any vehicles that are not functional after the inspection will have the shift mechanism and cable replaced with a "self-adjusting" design.

1998 Chrysler Sebring

Component

Steering:Wheel And Handle Bar

Consequence of Defect

this is not a safety recall in accordance with the safety act. however, it is deemed a safety improvement campaign by the agency. vehicle description: 1998-1999 chrysler sebring jxi limited convertibles. the steering column intermediate shaft coupler pinch bolt retaining pin could snag and/or fray the edge of the driver's side floor mat.

Corrective Action

this could interfere with the steering control of the vehicle.

Recall Notes

dealer will replace the steering column intermediate shaft coupler pinch bolt and retaining pin. in addition, the front floor mats will be replaced.

1998 Chrysler Sebring

Component

Fuel System, Gasoline:Delivery:Fuel Pump

Consequence of Defect

certain tigas fuel pump modules manufactured between june 1 and september 24, 2006, sold under various brand names and p/nos. these fuel pump modules are sold as aftermarket for use in certain daimlerchrysler vehicles listed above. silicone material used in manufacture of the flapper valve was out-of-specification, leading to excess swell of the flapper valve restricting the flow of fuel to the fuel pump module.

Corrective Action

fuel restriction could result in loss of power and/or engine stall, possibly resulting in a vehicle crash.

Recall Notes

ti automotive will notify owners and replace the defective fuel pump modules free of charge. the recall began on october 6, 2006. owners may contact ti automotive toll-free at 1-866-867-3759.

1997 Chrysler Sebring

Component

Vehicle Speed Control

Consequence of Defect

on certain passenger vehicles equipped with 2.5l v6 engines, the throttle control cable can fray causing the throttle to bind or stick.

Corrective Action

this could potentially result in a loss of throttle control, increasing the risk of a crash.

Recall Notes

dealers will replace the throttle cable assembly. owner notification began august 5, 2002. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact daimlerchrysler at 1-800-853-1403.

1997 Chrysler Sebring

Component

Seats:Front Assembly:Head Restraint

Consequence of Defect

the headrest guide bracket was improperly welded to the seat back frame on the passenger side seat back assemblies only.

Corrective Action

the headrest support bracket can break, increasing the risk of personal injury.

Recall Notes

dealers will replace the passenger seat back assembly with a new assembly.

1997 Chrysler Sebring

Component

Fuel System, Gasoline:Delivery:Fuel Pump

Consequence of Defect

certain airtex fuel pump modules, p/nos. e7089m, e7094m, e7113m, and e7129m, manufactured between june 1 and september 24, 2006. these fuel pump modules were sold as aftermarket for use in certain daimlerchrysler vehicles listed above. silicone material used in manufacture of the flapper valve was out-of-specification, leading to excess swell of the flapper valve restricting the flow of fuel to the fuel pump module.

Corrective Action

fuel restriction could result in loss of power and/or engine stall, possibly resulting in a vehicle crash.

Recall Notes

airtex will notify owners and replace the defective fuel pump modules free of charge. the recall began on october 18, 2006. owners may contact airtex toll-free at 1-866-867-3759.

1997 Chrysler Sebring

Component

Fuel System, Gasoline:Delivery:Fuel Pump

Consequence of Defect

certain airtex fuel pump module assemblies, p/n e7081h, sold for use as replacement equipment for the vehicles listed above. the wall of the flared fitting of the fuel pump is not thick enough to prevent the mating threaded fittings from bottoming out before an adequate seal is achieved. this condition may result in leakage of fuel at the connection of the vehicle fuel line and the fuel pump module assembly.

Corrective Action

in the presence of an ignition source, a fuel leak could result in a fire.

Recall Notes

airtex will notify owners and replace the fuel pumps free of charge. the recall is expected to begin during july 2007. owners can contact airtex automotive at 800-880-3056.

1997 Chrysler Sebring

Component

Exterior Lighting

Consequence of Defect

certain tradesonic combination lamps sold as replacement lamps for use on the above listed passenger vehicles. combination lamps not equipped with amber side reflectors fail to conform with the requirements of federal motor vehicle safety standard no. 108, lamps, reflective devices, and associated equipment.

Corrective Action

lack of amber side reflectors in the lamps will decrease lighting visibility to other drivers and may possibly result in a vehicle crash.

Recall Notes

tradesonic will notify owners and replace the lamps free of charge. the recall is expected to begin during july 2006. owners may contact tradesonic at 626-934-8884.

1997 Chrysler Sebring

Component

Suspension:Front:Control Arm:Lower Ball Joint

Consequence of Defect

vehicle description: passenger vehicles. if the rubber boots on the lower lateral arm ball joints of the front suspension were damaged during assembly, dirt and water can intrude. also, mmc has added the potential of leaking moisture, which can cause the ball stud to corrode.

Corrective Action

this condition could cause the lower lateral arm ball joint to separate, increasing the risk of a vehicle crash. this campaign supercedes mmc's previous safety recall campaign, see 99v-066.

Recall Notes

dealers will inspect the lower lateral arm ball joint for wear. ball joints that exhibit wear beyond the established tolerance will be replaced with newly designed lateral arm ball joints. ball joints that are within the established tolerance will be cleaned and a special sealant will be applied to prevent intrusion of moisture.

1997 Chrysler Sebring

Component

Structure:Body:Roof And Pillars

Consequence of Defect

this is not a safety recall in accordance with the safety act. however, it is deemed a safety improvement campaign by the agency. vehicle description: passenger vehicles. if the convertible top cover is not installed correctly, it can separate unexpectedly from the vehicle while driving.

Corrective Action

if the cover separates while driving, it could distract the driver increasing the risk of a crash.

Recall Notes

owners will receive an improved convertible top cover instruction label and installation instructions.

1997 Chrysler Sebring

Component

Power Train:Automatic Transmission:Park/Neutral Start Switch

Consequence of Defect

vehicle description: passenger vehicles equipped with automatic transmissions. the adjustment of the cable connecting the console shifter mechanism to the ignition key can cause a trapped key condition which can result in a low force required to depress the shift button. a combination of applying a mis-adjusted release button with a low force attempt to shift out of park with the key in the locked position, can break the connecting pin in the shifter.

Corrective Action

if this happens, the "ignition-park" interlock system will be nonfunctional.

Recall Notes

dealers will inspect for proper operation of the system. any vehicles that are not functional after the inspection will have the shift mechanism and cable replaced with a "self-adjusting" design.

1997 Chrysler Sebring

Component

Suspension:Front:Control Arm:Lower Ball Joint

Consequence of Defect

vehicle description: passenger vehicles. the lower control arm ball joint can separate due to loss of lubrication.

Corrective Action

separation of the ball joint could cause a loss of steering control increasing the risk of a vehicle crash.

Recall Notes

dealers will inspect the ball joint end housing cover seal for leakage with a high pressure air tester and the rubber boot will be visually inspected for damage. if the cover seal leaks or the boot is damaged, the lower control arm will be replaced.

1997 Chrysler Sebring

Component

Fuel System, Gasoline:Delivery:Fuel Pump

Consequence of Defect

certain tigas fuel pump modules manufactured between june 1 and september 24, 2006, sold under various brand names and p/nos. these fuel pump modules are sold as aftermarket for use in certain daimlerchrysler vehicles listed above. silicone material used in manufacture of the flapper valve was out-of-specification, leading to excess swell of the flapper valve restricting the flow of fuel to the fuel pump module.

Corrective Action

fuel restriction could result in loss of power and/or engine stall, possibly resulting in a vehicle crash.

Recall Notes

ti automotive will notify owners and replace the defective fuel pump modules free of charge. the recall began on october 6, 2006. owners may contact ti automotive toll-free at 1-866-867-3759.

1996 Chrysler Sebring

Component

Vehicle Speed Control

Consequence of Defect

on certain passenger vehicles equipped with 2.5l v6 engines, the throttle control cable can fray causing the throttle to bind or stick.

Corrective Action

this could potentially result in a loss of throttle control, increasing the risk of a crash.

Recall Notes

dealers will replace the throttle cable assembly. owner notification began august 5, 2002. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact daimlerchrysler at 1-800-853-1403.

1996 Chrysler Sebring

Component

Fuel System, Gasoline:Delivery:Fuel Pump

Consequence of Defect

certain airtex fuel pump modules, p/nos. e7089m, e7094m, e7113m, and e7129m, manufactured between june 1 and september 24, 2006. these fuel pump modules were sold as aftermarket for use in certain daimlerchrysler vehicles listed above. silicone material used in manufacture of the flapper valve was out-of-specification, leading to excess swell of the flapper valve restricting the flow of fuel to the fuel pump module.

Corrective Action

fuel restriction could result in loss of power and/or engine stall, possibly resulting in a vehicle crash.

Recall Notes

airtex will notify owners and replace the defective fuel pump modules free of charge. the recall began on october 18, 2006. owners may contact airtex toll-free at 1-866-867-3759.

1996 Chrysler Sebring

Component

Fuel System, Gasoline:Delivery:Fuel Pump

Consequence of Defect

certain airtex fuel pump module assemblies, p/n e7081h, sold for use as replacement equipment for the vehicles listed above. the wall of the flared fitting of the fuel pump is not thick enough to prevent the mating threaded fittings from bottoming out before an adequate seal is achieved. this condition may result in leakage of fuel at the connection of the vehicle fuel line and the fuel pump module assembly.

Corrective Action

in the presence of an ignition source, a fuel leak could result in a fire.

Recall Notes

airtex will notify owners and replace the fuel pumps free of charge. the recall is expected to begin during july 2007. owners can contact airtex automotive at 800-880-3056.

1996 Chrysler Sebring

Component

Suspension:Front:Control Arm:Lower Ball Joint

Consequence of Defect

vehicle description: passenger vehicles. if the rubber boots on the lower lateral arm ball joints of the front suspension were damaged during assembly, dirt and water can intrude.

Corrective Action

this condition could cause the lower lateral arm ball joint to separate, increasing the risk of a vehicle crash.

Recall Notes

dealers will inspect the rubber boots, and if the boot is damaged, they will replace the lower lateral arm and ball joint on the affected vehicles.

1996 Chrysler Sebring

Component

Service Brakes, Hydraulic:Power Assist

Consequence of Defect

the power brake booster vacuum hose was improperly installed on the intake manifold vacuum nipple.

Corrective Action

a disconnected vacuum hose causes an increase in engine idle speed and loss of power assist during brake application increasing the risk of a vehicle accident.

Recall Notes

dealers will fully install the intake manifold vacuum hose to the vacuum nipple on the intake manifold.

1996 Chrysler Sebring

Component

Suspension:Front:Control Arm:Lower Ball Joint

Consequence of Defect

vehicle description: passenger vehicles. if the rubber boots on the lower lateral arm ball joints of the front suspension were damaged during assembly, dirt and water can intrude. also, mmc has added the potential of leaking moisture, which can cause the ball stud to corrode.

Corrective Action

this condition could cause the lower lateral arm ball joint to separate, increasing the risk of a vehicle crash. this campaign supercedes mmc's previous safety recall campaign, see 99v-066.

Recall Notes

dealers will inspect the lower lateral arm ball joint for wear. ball joints that exhibit wear beyond the established tolerance will be replaced with newly designed lateral arm ball joints. ball joints that are within the established tolerance will be cleaned and a special sealant will be applied to prevent intrusion of moisture.

1996 Chrysler Sebring

Component

Structure:Body:Roof And Pillars

Consequence of Defect

this is not a safety recall in accordance with the safety act. however, it is deemed a safety improvement campaign by the agency. vehicle description: passenger vehicles. if the convertible top cover is not installed correctly, it can separate unexpectedly from the vehicle while driving.

Corrective Action

if the cover separates while driving, it could distract the driver increasing the risk of a crash.

Recall Notes

owners will receive an improved convertible top cover instruction label and installation instructions.

1996 Chrysler Sebring

Component

Power Train:Automatic Transmission:Park/Neutral Start Switch

Consequence of Defect

vehicle description: passenger vehicles equipped with automatic transmissions. the adjustment of the cable connecting the console shifter mechanism to the ignition key can cause a trapped key condition which can result in a low force required to depress the shift button. a combination of applying a mis-adjusted release button with a low force attempt to shift out of park with the key in the locked position, can break the connecting pin in the shifter.

Corrective Action

if this happens, the "ignition-park" interlock system will be nonfunctional.

Recall Notes

dealers will inspect for proper operation of the system. any vehicles that are not functional after the inspection will have the shift mechanism and cable replaced with a "self-adjusting" design.

1996 Chrysler Sebring

Component

Visibility:Rearview Mirrors/Devices

Consequence of Defect

the electrical contacts in the power mirror switch can accumulate road salt due to water entering into the switch.

Corrective Action

this can result in a high resistance short circuit and possibly cause a vehicle fire.

Recall Notes

dealers will replace the power mirror switch with a newly designed switch.

1996 Chrysler Sebring

Component

Suspension:Front:Control Arm:Lower Ball Joint

Consequence of Defect

vehicle description: passenger vehicles. the lower control arm ball joint can separate due to loss of lubrication.

Corrective Action

separation of the ball joint could cause a loss of steering control increasing the risk of a vehicle crash.

Recall Notes

dealers will inspect the ball joint end housing cover seal for leakage with a high pressure air tester and the rubber boot will be visually inspected for damage. if the cover seal leaks or the boot is damaged, the lower control arm will be replaced.

1996 Chrysler Sebring

Component

Fuel System, Gasoline:Delivery:Fuel Pump

Consequence of Defect

certain tigas fuel pump modules manufactured between june 1 and september 24, 2006, sold under various brand names and p/nos. these fuel pump modules are sold as aftermarket for use in certain daimlerchrysler vehicles listed above. silicone material used in manufacture of the flapper valve was out-of-specification, leading to excess swell of the flapper valve restricting the flow of fuel to the fuel pump module.

Corrective Action

fuel restriction could result in loss of power and/or engine stall, possibly resulting in a vehicle crash.

Recall Notes

ti automotive will notify owners and replace the defective fuel pump modules free of charge. the recall began on october 6, 2006. owners may contact ti automotive toll-free at 1-866-867-3759.

1995 Chrysler Sebring

Component

Fuel System, Gasoline:Delivery:Fuel Pump

Consequence of Defect

certain airtex fuel pump module assemblies, p/n e7081h, sold for use as replacement equipment for the vehicles listed above. the wall of the flared fitting of the fuel pump is not thick enough to prevent the mating threaded fittings from bottoming out before an adequate seal is achieved. this condition may result in leakage of fuel at the connection of the vehicle fuel line and the fuel pump module assembly.

Corrective Action

in the presence of an ignition source, a fuel leak could result in a fire.

Recall Notes

airtex will notify owners and replace the fuel pumps free of charge. the recall is expected to begin during july 2007. owners can contact airtex automotive at 800-880-3056.

1995 Chrysler Sebring

Component

Suspension:Front:Control Arm:Lower Ball Joint

Consequence of Defect

vehicle description: passenger vehicles. if the rubber boots on the lower lateral arm ball joints of the front suspension were damaged during assembly, dirt and water can intrude.

Corrective Action

this condition could cause the lower lateral arm ball joint to separate, increasing the risk of a vehicle crash.

Recall Notes

dealers will inspect the rubber boots, and if the boot is damaged, they will replace the lower lateral arm and ball joint on the affected vehicles.

1995 Chrysler Sebring

Component

Suspension:Front:Control Arm:Lower Ball Joint

Consequence of Defect

vehicle description: passenger vehicles. if the rubber boots on the lower lateral arm ball joints of the front suspension were damaged during assembly, dirt and water can intrude. also, mmc has added the potential of leaking moisture, which can cause the ball stud to corrode.

Corrective Action

this condition could cause the lower lateral arm ball joint to separate, increasing the risk of a vehicle crash. this campaign supercedes mmc's previous safety recall campaign, see 99v-066.

Recall Notes

dealers will inspect the lower lateral arm ball joint for wear. ball joints that exhibit wear beyond the established tolerance will be replaced with newly designed lateral arm ball joints. ball joints that are within the established tolerance will be cleaned and a special sealant will be applied to prevent intrusion of moisture.

1995 Chrysler Sebring

Component

Suspension:Front:Control Arm:Lower Ball Joint

Consequence of Defect

vehicle description: passenger vehicles. the lower control arm ball joint can separate due to loss of lubrication.

Corrective Action

separation of the ball joint could cause a loss of steering control increasing the risk of a vehicle crash.

Recall Notes

dealers will inspect the ball joint end housing cover seal for leakage with a high pressure air tester and the rubber boot will be visually inspected for damage. if the cover seal leaks or the boot is damaged, the lower control arm will be replaced.

1995 Chrysler Sebring

Component

Fuel System, Gasoline:Delivery:Fuel Pump

Consequence of Defect

certain tigas fuel pump modules manufactured between june 1 and september 24, 2006, sold under various brand names and p/nos. these fuel pump modules are sold as aftermarket for use in certain daimlerchrysler vehicles listed above. silicone material used in manufacture of the flapper valve was out-of-specification, leading to excess swell of the flapper valve restricting the flow of fuel to the fuel pump module.

Corrective Action

fuel restriction could result in loss of power and/or engine stall, possibly resulting in a vehicle crash.

Recall Notes

ti automotive will notify owners and replace the defective fuel pump modules free of charge. the recall began on october 6, 2006. owners may contact ti automotive toll-free at 1-866-867-3759.