Lemon Law Center

Home > Chrysler

1992 Chrysler Fifth Avenue

Component

Steering:Wheel And Handle Bar

Consequence of Defect

the zinc plating operation performed on the upper steering column shaft coupling bolt caused hydrogen embrittlement and breakage of the bolt.

Corrective Action

fractures of the upper steering column shaft couplingbolt result in a lack of coupling load on the shaft and loss of steeringcontrol.

Recall Notes

replace the zinc plated bolt with a phosphate plated bolt.

1991 Chrysler Fifth Avenue

Component

Service Brakes, Hydraulic:Foundation Components:Disc:Caliper

Consequence of Defect

front disc brake caliper guide pin bolts may not have been adequately torqued and could loosen.

Corrective Action

this could cause reduced braking effectiveness and couldresult in an accident.

Recall Notes

properly torque front brake caliper guide pin bolts to 250 pounds.

1991 Chrysler Fifth Avenue

Component

Seat Belts:Front:Anchorage

Consequence of Defect

front outboard safety belt may become difficult to latch and or unlatch due to a webbing stiffener entering the buckle housing and dislodging the buckle latch guide.

Corrective Action

latch may open during accident or sudden stop, exposingseat occupant to increased risk of injury.

Recall Notes

replace buckle latch engagement.

1991 Chrysler Fifth Avenue

Component

Visibility:Defroster/Defogger System:Windshield:Blower

Consequence of Defect

water leaking under windshield cowl in area above heater blower motor resistor block results in corrosion of the resistor terminals.

Corrective Action

corrosion of the resistor terminals increases electricalresistance, leading to overheating and possble ignition of the wiring connectorsand insulation, causing a fire in the cowl area.

Recall Notes

the blower motor resistor block will be replaced, and a mastic patch applied to seal the cowl against water entry. damaged wire connectors will be replaced.

1990 Chrysler Fifth Avenue

Component

Air Bags:Frontal:Sensor/Control Module

Consequence of Defect

air bag inflator modules may not contain diffuser holes between the ignitor and propellant chambers.

Corrective Action

air bags would not deploy in an impact situation, which could lead to driver injury.

Recall Notes

replace air bag inflator modules with properly machined modules.

1988 Chrysler Fifth Avenue

Component

Electrical System:Wiring:Front Underhood

Consequence of Defect

engine compartment wiring harness fusible link wires may be trapped under the speed control servo bracket.

Corrective Action

trapped wires may eventually cause a high resistanceelectrical short that can result in an underhood fire.

Recall Notes

free any trapped wiring; then secure wiring with a tie strap to keep away from speed control bracket.