Lemon Law Center :: Buick Regal :: Lemon Law Attorneys

vehicle description: passenger vehicles. some of these vehicles exhibit a condition in which the driver side impact air bag inflator separates from the air bag module during deployment.

Corrective Action

if the inflator separates, the air bag will not deploy properly during a crash and occupant protection would be reduced. if is also possible that a separated inflator could be propelled downward and could result in injury to a rear seat passenger whose foot is positioned approximately under the inflator module.

Recall Notes

dealers will replace the side impact air bag module.

2001 Buick Regal

Component

Seat Belts

Consequence of Defect

vehicle description: passenger vehicles, light duty trucks, sport utility vehicles, and mini vans equipped with trw seat belt buckle assemblies. the buckle base of these seat belt assemblies were not properly heat treated and therefore do not pass the load bearing requirement of federal motor vehicle safety standard no. 209, "seat belt assemblies."

Corrective Action

in the event of a vehicle crash, the occupant may not be properly restrained.

Recall Notes

dealers will inspect the vehicle's safety belt buckle assembly date codes and, if necessary, will replace any safety belt buckle assembly.

2001 Buick Regal

Component

Seat Belts

Consequence of Defect

vehicle description: certain passenger vehicles, equipped with sunvisor located air bag labels, fail to conform to federal motor vehicles safety standard no. 208, "occupant crash protection." these vehicles have a message area less than 30 cm which does not meet the requirements of the standard.

Corrective Action

these vehicles do not comply with the standard.

Recall Notes

gm will mail a new bilingual air bag label with installation instructions. however, the customer may bring the label to their dealer for installation free of charge. owner notification began may 4, 2001. owners who do not receive the free label and installation instructions within a reasonable time should contact oldsmobile at 1-800-442-6537 or buick at 1-800-521-7300.

2000 Buick Regal

Component

Air Bags:Side/Window

Consequence of Defect

vehicle description: passenger vehicles. some of these vehicles exhibit a condition in which the driver side impact air bag inflator separates from the air bag module during deployment.

Corrective Action

Recall Notes

dealers will replace the side impact air bag module.

2000 Buick Regal

Component

Seat Belts

Consequence of Defect

Corrective Action

in the event of a vehicle crash, the occupant may not be properly restrained.

Recall Notes

dealers will inspect the vehicle's safety belt buckle assembly date codes and, if necessary, will replace any safety belt buckle assembly.

2000 Buick Regal

Component

Fuel System, Gasoline:Storage:Tank Assembly:Filler Pipe And Cap

Consequence of Defect

vehicle description: passenger vehicles. the clamp that secures the flexible fuel fill hose to the metal fill tube may be loose and could separate.

Corrective Action

this could cause fuel leakage exceeding the permissible amount.

Recall Notes

dealers will inspect the fuel hose fill neck clamp and, if necessary, reposition and tighten the clamp.

2000 Buick Regal

Component

Seat Belts

Consequence of Defect

Corrective Action

these vehicles do not comply with the standard.

Recall Notes

2000 Buick Regal

Component

Service Brakes, Hydraulic:Foundation Components:Drum

Consequence of Defect

vehicle description: passenger vehicles equipped with rear drum brakes. the bolt head(s) on the rear spindle rod can separate.

Corrective Action

the rear wheel can shift, causing rear steering of the vehicle. the driver could lose control and a crash could occur.

Recall Notes

dealers will replace the rear spindle bolts.

1999 Buick Regal

Component

Exterior Lighting:Headlights

Consequence of Defect

vehicle description: passenger vehicles. these vehicles do not conform to the requirements of fmvss no. 108, "lamps, reflective devices, and associated equipment." the vertical head lamp adjusting device may not be calibrated properly.

Corrective Action

driver visibility may be impaired increasing the risk of a crash.

Recall Notes

owners will be provided with an owner's manual insert containing instructions for optically aiming the headlamps.

1999 Buick Regal

Component

Service Brakes, Hydraulic:Antilock

Consequence of Defect

some of these vehicles with the key in the "on" position, exhibit a condition in which the antilock brake system (abs) motor shorts to its case and grounds through a flexible brake fluid pipe.

Corrective Action

this short can cause extreme heating of the flexible brake pipe where it can melt a nearby flexible plastic fuel hose, which could result in an underhood fire.

Recall Notes

dealers will install a ground cable from the electronic brake control module (ebcm) to the engine compartment body rail.

1999 Buick Regal

Component

Exterior Lighting:Headlights

Consequence of Defect

certain passenger vehicles do not conform to the requirements of federal motor vehicle safety standard no. 108, "lamps, reflective devices, and associated equipment." some of these vehicles do not meet the overhead sign illumination requirements.

Corrective Action

less illumination may reduce the ability of the driver to read overhead signs when driving at night.

Recall Notes

dealers will install new low beam headlamp bulbs in both of the headlamp assemblies. the recall began on september 8, 2004. owners should contact buick at 1-866-608-8080. note: if the bulb needs replacement in the future, gm bulb number 89024715 is available from a dealer, or the equivalent sylvania bulb is 9006hp, with orange lettering on the bulb.

1998 Buick Regal

Component

Exterior Lighting:Headlights

Consequence of Defect

Corrective Action

driver visibility may be impaired increasing the risk of a crash.

Recall Notes

owners will be provided with an owner's manual insert containing instructions for optically aiming the headlamps.

1998 Buick Regal

Component

Exterior Lighting:Headlights

Consequence of Defect

vehicle description: passenger vehicles. the owner manuals do not contain the requirement information pertaining to the vehicle headlamp aiming device. this does not comply with requirements of fmvss no. 108, "lamps, reflective devices, and associated equipment."

Corrective Action

if the headlamp assemblies are replaced, customers may not be able to properly aim the headlights.

Recall Notes

owners will be mailed an owner manual's insert which contains the appropriate information.

1998 Buick Regal

Component

Steering:Rack And Pinion

Consequence of Defect

certain passenger vehicles have lower pinion bearings in the power rack and pinion assembly in which the retainer tabs were not crimped properly. these retainers could fail and permit the ball bearings to escape.

Corrective Action

if this occurs, the pinion shaft can be forced upward during left turns and back down as the steering wheel is moved back and to the right. if the pinion shaft moves further, the driver will need to exert more effort to turn the steering wheel, similar to a vehicle without power assisted steering. if the pinion shaft moves even further, the driver will require much higher effort to turn left and may not be able to turn the wheel as much as intended. with the maximum pinion shaft movement, which requires internal gear component damage, the driver can encounter high resistance to turning left, followed by unintended power assist to the right. in any of these conditions, a crash could occur.

Recall Notes

dealers will install a new lower pinion bearing unless inspect of the existing bearing indicates that replacement of the gear assembly is necessary. owner notification began on february 5, 2004. owners should contact buick at 1-866-608-8080; chevrolet at 1-800-630-2438; oldsmobile at 1-800-630-6537; or pontiac at 1-800-620-7668.

1997 Buick Regal

Component

Exterior Lighting:Headlights

Consequence of Defect

Corrective Action

if the headlamp assemblies are replaced, customers may not be able to properly aim the headlights.

Recall Notes

owners will be mailed an owner manual's insert which contains the appropriate information.

1997 Buick Regal

Component

Steering:Rack And Pinion

Consequence of Defect

Corrective Action

Recall Notes

1997 Buick Regal

Component

Service Brakes, Hydraulic:Foundation Components:Hoses, Lines/Piping, And Fittings

Consequence of Defect

vehicle description: passenger vehicles. the right front brake pipe can contact the piower steering assembly causing the brake line to wear through.

Corrective Action

this condition can result in the loss of brake fluid and eventual loss of half of the vehicle brake system.

Recall Notes

dealers will inspect for proper clearance between the brake line and power steering assembly. assemblies found to be out of position will be repositioned and all assemblies secured to maintain proper clearances. additionally, those brake lines found to have been damaged will be replaced and properly routed.

1997 Buick Regal

Component

Visibility:Windshield Wiper/Washer:Linkages

Consequence of Defect

vehicle description: passenger vehicles. the windshield wipers may stop working due to a separation between the drive pin and crescent in the crank arm assembly.

Corrective Action

driver visibility could be reduced, increasing the risk of a crash.

Recall Notes

dealers will inspect these vehicles for the presence of a plastic water deflector and, if necessary, replace the wiper motor crank arm and install a water deflector. on vehicles receiving a replacement crank arm and new water deflector, dealers will also apply additional sealing material to improve water deflection away from the crank arm assembly and will install a reinforcement to improve the performance of the wiper park mechanism.

1996 Buick Regal

Component

Steering:Rack And Pinion

Consequence of Defect

Corrective Action

Recall Notes

1996 Buick Regal

Component

Fuel System, Gasoline:Fuel Injection System

Consequence of Defect

a backfire during engine starting can cause breakage of the upper intake manifold.

Corrective Action

this condition can cause a no-start condition and possibly an engine compartment fire.

Recall Notes

dealers will update the powertrain control module programming. until the campaign repair is made, the vehicle hood should be shut whenever starting the vehicle to reduce the chance of personal injury.

1996 Buick Regal

Component

Service Brakes, Hydraulic:Foundation Components:Hoses, Lines/Piping, And Fittings

Consequence of Defect

the left front brake line can contact the transaxle mounting bracket or attachment bolt.

Corrective Action

this condition can cause the brake line to wear through, resulting in loss of brake fluid and eventual loss of one-half of the vehicle's brake system, increasing the potential for a vehicle accident.

Recall Notes

dealers will inspect the vehicle for proper brake line clearance and reposition those brake lines found to have less than minimal clearance. additionally, those brake lines found to have an indentation caused by the contact will be replaced and properly routed.

1996 Buick Regal

Component

Fuel System, Other:Storage:Tank Assembly:Pressure Relief Devices

Consequence of Defect

certain delphi fuel pressure regulators, p/nos. fp10020-11b1, fp10026-11b1, and fp10027-11b1, sold after january 9, 2007, as aftermarket equipment for various passenger vehicles listed above. the universal pressure regulators (upr) were produced without an o'ring and retainer.

Corrective Action

fuel may leak, possibly resulting in a fire.

Recall Notes

delphi will notify owners and replace the upr free of charge. the recall began on april 23, 2007. owners can contact delphi at 877-411-8770.

1995 Buick Regal

Component

Seat Belts:Front:Anchorage

Consequence of Defect

the center rear seat belt anchor plate exhibits stress cracks.

Corrective Action

in the event of a vehicle crash, the seat belt system can fracture, increasing the risk of injury to the seat occupant.

Recall Notes

dealers will replace the center rear seat belt system.

1995 Buick Regal

Component

Seat Belts:Front:Anchorage

Consequence of Defect

the center rear seat belt anchor plate exhibits stress cracks.

Corrective Action

in the event of a vehicle crash, the seat belt system can fracture and injury to the seat occupant can occur.

Recall Notes

dealers will replace the center rear seat belt system.

1995 Buick Regal

Component

Steering:Wheel And Handle Bar

Consequence of Defect

the four (4) steering column support bracket attaching bolts were under torqued during assembly.

Corrective Action

inadequate torque can cause these bolts to vibrate, loosen, or fall out resulting in loss of steering control and increase the potential for a vehicle crash.

Recall Notes

dealers will retorque the steering column support bracket attaching bolts to the correct specifications.

1995 Buick Regal

Component

Air Bags:Frontal

Consequence of Defect

vehicle description: passenger vehicles. corrosion of the air bag inflator's internal wiring, which can occur over time, could cause the inadvertent deployment of the driver's air bag. this deployment could occur during vehicle start-up, while the vehicle is parked or idling, or while in operation.

Corrective Action

if the consumer is too close to an inflating air bag, serious injuries could occur.

Recall Notes

dealers will replace the inflators on these air bags.

1995 Buick Regal

Component

Exterior Lighting

Consequence of Defect

incorrect clear front side marker bulbs were installed rather than amber bulbs. this does not conform to the requirements of fmvss no. 108, "lamps, reflective devices, and associated equipment."

Corrective Action

consequence of non-compliance: during illumination, the bulbs will show clear rather than amber and could momentarily confuse other drivers.

Recall Notes

dealers will replace the clear bulbs with the correct amber bulbs.

1995 Buick Regal

Component

Service Brakes, Hydraulic:Foundation Components:Hoses, Lines/Piping, And Fittings

Consequence of Defect

the rear wheel brake hose(s) can contact the rear suspension components causing the brake hose(s) to wear through.

Corrective Action

this condition can cause loss of brake fluid and eventual loss of the vehicle braking system increasing the potential for a vehicle accident.

Recall Notes

dealers will inspect for proper brake hose position and replace those hoses in an incorrect position with new hoses and correctly routed.

1995 Buick Regal

Component

Exterior Lighting

Consequence of Defect

the vehicles were assembled with an incorrect front park/turn signal bulb which does not have sufficient candle power. this does not comply with fmvss no. 108, "lamps, reflective devices, and associated equipment."

Corrective Action

consequence of non-compliance: operators could fail to notice and heed the warning labels. reduces candle power on the park/turn lights decreases the liklihood of vehicle operator's intent being seen by other motorists.

Recall Notes

dealers will replace the incorrect bulb with the correct bulb.

1995 Buick Regal

Component

Visibility:Windshield Wiper/Washer:Switch/Wiring

Consequence of Defect

some of these vehicles have a strained or separated washer/wiper switch power feed wire.

Corrective Action

this can cause the windshield washer/wiper to work intermittently and could ultimately result in inoperative wipers. if this were to occur in a severe weather situation, driver visibility could be reduced, increasing the risk of a vehicle crash.

Recall Notes

dealers will inspect and replace the old designed washer/wiper switches with a newly designed switch.

1994 Buick Regal

Component

Exterior Lighting

Consequence of Defect

incorrect clear front side marker bulbs were installed rather than amber bulbs. this does not conform to the requirements of fmvss no. 108, "lamps, reflective devices, and associated equipment."

Corrective Action

consequence of non-compliance: during illumination, the bulbs will show clear rather than amber and could momentarily confuse other drivers.

Recall Notes

dealers will replace the clear bulbs with the correct amber bulbs.

1994 Buick Regal

Component

Service Brakes, Hydraulic:Foundation Components:Hoses, Lines/Piping, And Fittings

Consequence of Defect

the rear wheel brake hose(s) can contact the rear suspension components causing the brake hose(s) to wear through.

Corrective Action

this condition can cause loss of brake fluid and eventual loss of the vehicle braking system increasing the potential for a vehicle accident.

Recall Notes

dealers will inspect for proper brake hose position and replace those hoses in an incorrect position with new hoses and correctly routed.

1994 Buick Regal

Component

Visibility:Windshield Wiper/Washer:Switch/Wiring

Consequence of Defect

some of these vehicles have a strained or separated washer/wiper switch power feed wire.

Corrective Action

Recall Notes

dealers will inspect and replace the old designed washer/wiper switches with a newly designed switch.

1993 Buick Regal

Component

Seats

Consequence of Defect

the driver and passenger front seat manual reclining mechanisms do not comply with the requirements of fmvss 207, "seating systems." the seat back mechanisms will not latch under certain conditions.

Corrective Action

the seats may recline without prior warning, resultingin a hazard to seat occupants and possible loss of vehicle control.

Recall Notes

replace the manual seat recliner mechanism with a mechanism that complies with fmvss 207.

1993 Buick Regal

Component

Exterior Lighting

Consequence of Defect

incorrect clear front side marker bulbs were installed rather than amber bulbs. this does not conform to the requirements of fmvss no. 108, "lamps, reflective devices, and associated equipment."

Corrective Action

consequence of non-compliance: during illumination, the bulbs will show clear rather than amber and could momentarily confuse other drivers.

Recall Notes

dealers will replace the clear bulbs with the correct amber bulbs.

1992 Buick Regal

Component

Power Train:Automatic Transmission

Consequence of Defect

the reverse servo apply pin may bind in the case which could cause reverse band distress (loss or slipping of reverse), reverse band drag in drive range (poor performance -- poor power), or the transmission to remain in reverse while the shift indicator shows neutral gear position.

Corrective Action

if the transmission remains in reverse while the shiftindicator shows neutral, the vehicle may unexpectedly move rearward and resultin a vehicle accident.

Recall Notes

replace the transaxle where required.

1992 Buick Regal

Component

Exterior Lighting

Consequence of Defect

incorrect clear front side marker bulbs were installed rather than amber bulbs. this does not conform to the requirements of fmvss no. 108, "lamps, reflective devices, and associated equipment."

Corrective Action

consequence of non-compliance: during illumination, the bulbs will show clear rather than amber and could momentarily confuse other drivers.

Recall Notes

dealers will replace the clear bulbs with the correct amber bulbs.

1991 Buick Regal

Component

Fuel System, Gasoline

Consequence of Defect

certain replacement fuel filters, fram brand name p/n g3727, with date codes x52911 through x60801 sequentially or x600141 and a mexico country or origin marking on the fuel filter housing manufactured from october 18, 2005, through march 21, 2006, sold for use on the vehicles listed above and on certain school buses. (to see the school bus engine sizes, click on "document search" and then "bus applications"). the connector on the fuel filter was not manufactured to honeywell's specification. as a result, the o-ring may not seat correctly on the fuel line.

Corrective Action

this condition may cause an inadequate seal at the connection, potentially leading to a fuel leak. in the presence of an ignition source, a fire could occur.

Recall Notes

honeywell will notify owners and replace the fuel filters free of charge. the recall began on october 18, 2006. owners may contact fram customer service at 1-800-890-2075 (option 1).

1991 Buick Regal

Component

Structure

Consequence of Defect

vehicle description: passenger vehicles originally sold or currently registered in the states of connecticut, delaware, illinois, indiana, iowa, maine, maryland, massachusetts, michigan, minnesota, missouri, new hampshire, new jersey, new york, ohio, pennsylvania, rhode island, vermont, west virginia, wisconsin, and the district of columbia, where road salt use is heavy. a condition where one or both front engine cradle bolts can pull through the retainers due to corrosion of the retainers.

Corrective Action

if both bolts pull through, the front of the cradle would no longer be supported at the mounting locations and the steering intermediate shaft could separate from the steering gear.

Recall Notes

dealers will replace the front and rear frame/cradle bolts and retainers.

1991 Buick Regal

Component

Structure

Consequence of Defect

vehicle description: passenger vehicles and mini vans originally sold or currently registered in the following states: connecticut, illinois, indiana, maine, massachusetts, michigan, new hampshire, new jersey, new york, ohio, pennsylvania, rhode island, vermont and wisconsin. the rear cradle bolts pull through the retainers due to corrosion of the retainer. if both bolts pull through, the rear cradle would not longer be supported at these mounting locations and the steering intermediate shaft can separate from the steering gear.

Corrective Action

if this were to occur while the vehicle was in motion, a vehicle crash could result.

Recall Notes

dealers will replace the rear cradle bolts and retainers.

1991 Buick Regal

Component

Exterior Lighting

Consequence of Defect

incorrect clear front side marker bulbs were installed rather than amber bulbs. this does not conform to the requirements of fmvss no. 108, "lamps, reflective devices, and associated equipment."

Corrective Action

consequence of non-compliance: during illumination, the bulbs will show clear rather than amber and could momentarily confuse other drivers.

Recall Notes

dealers will replace the clear bulbs with the correct amber bulbs.

1991 Buick Regal

Component

Seat Belts

Consequence of Defect

the front door shoulder belt guide loops may be cracked and are not in compliance with fmvss 208.

Corrective Action

the seat occupant faces increased risk of injury in theevent of a sudden stop or accident.

Recall Notes

install reinforcing plates on the cracked shoulder belt guides.

1991 Buick Regal

Component

Seat Belts

Consequence of Defect

front shoulder safety belt webbing may separate at front belt upper guide loops on either side of the front seat.

Corrective Action

webbing separation could occur without prior warning andincrease the risk of injury to belted front outboard occupants in a high energycrash.

Recall Notes

install a controlled rotation bracket on driver and passenger side front seat belt guide loops.

1991 Buick Regal

Component

Fuel System, Gasoline:Delivery:Hoses, Lines/Piping, And Fittings

Consequence of Defect

the fuel feed hose can pull out of the crimped coupling at the engine end of the hose assembly, causing fuel leakage.

Corrective Action

if the coupling were to separate and an ignition sourceis present, an engine compartment fire could occur.

Recall Notes

install a new fuel feed hose.

1990 Buick Regal

Component

Exterior Lighting:Brake Lights:Switch

Consequence of Defect

brake stoplamps may not illuminate or, in some cases, stoplamps will not stay illuminated all the time when brakes are applied due to a faulty stoplamp switch. also in vehicles equipped with cruise control, a faulty stoplamp switch can result in resumption of the cruise control function upon release of the brake pedal.

Corrective Action

a trailing vehicle may not recognize a braking actionin time to respond appropriately. also, cruise control will reengage uponrelease of the brake pedal and resume the set speed. in either case, it couldresult in a crash without prior warning.

Recall Notes

install an improved design stoplamp switch.

1990 Buick Regal

Component

Fuel System, Gasoline

Consequence of Defect

Corrective Action

this condition may cause an inadequate seal at the connection, potentially leading to a fuel leak. in the presence of an ignition source, a fire could occur.

Recall Notes

honeywell will notify owners and replace the fuel filters free of charge. the recall began on october 18, 2006. owners may contact fram customer service at 1-800-890-2075 (option 1).

1990 Buick Regal

Component

Seat Belts:Front:Webbing

Consequence of Defect

owners manuals did not fully explain how front shoulder belt comfort feature works.

Corrective Action

cars would not comply with fmvss 208, and incorrect use of safety restraints could lead to personal injury to occupants if an accidentshould occur.

Recall Notes

insert sticker that provides missing information in owners manuals.

1990 Buick Regal

Component

Structure

Consequence of Defect

Corrective Action

if both bolts pull through, the front of the cradle would no longer be supported at the mounting locations and the steering intermediate shaft could separate from the steering gear.

Recall Notes

dealers will replace the front and rear frame/cradle bolts and retainers.

1990 Buick Regal

Component

Structure

Consequence of Defect

Corrective Action

if this were to occur while the vehicle was in motion, a vehicle crash could result.

Recall Notes

dealers will replace the rear cradle bolts and retainers.

1990 Buick Regal

Component

Seat Belts

Consequence of Defect

front shoulder safety belt webbing may separate at front belt upper guide loops on either side of the front seat.

Corrective Action

webbing separation could occur without prior warning andincrease the risk of injury to belted front outboard occupants in a high energycrash.

Recall Notes

install a controlled rotation bracket on driver and passenger side front seat belt guide loops.

1990 Buick Regal

Component

Wheels

Consequence of Defect

cracks develop in the wheel mounting surface. if these cracks become severe enough, the wheel will completely separate from the vehicle.

Corrective Action

if wheel separation occurs while the vehicle is in motion, loss of steering and brake control of the vehicle occurs, and a vehicle crash could result without prior warning.

Recall Notes

dealers will inspect the manufacturing date codes stamped on each wheel of the vehicle and if a wheel falls within the specified date code range, the dealer will replace that wheel assembly.

1990 Buick Regal

Component

Wheels

Consequence of Defect

cracks develop in the wheel mounting surface. if these cracks become severe enough, the wheel will completely separate from the vehicle.

Corrective Action

if wheel separation occurs while the vehicle is in motion, loss of steering and brake control of the vehicle occurs, and a vehicle crash could result without prior warning.

Recall Notes

dealers will inspect the manufacturing codes stamped on each wheel of the vehicle and if a wheel falls within the specified date code range, the dealer will replace that wheel assembly.

1990 Buick Regal

Component

Seat Belts

Consequence of Defect

front shoulder belt guide loop attachment fastener may pull through door mounted anchor plate.

Corrective Action

seat belt may not sustain loads required by fmvss 210, and in a vehicle accident, the seat belt may not properly restrain a passenger, resulting in increased risk of greater injury to an occupant.

Recall Notes

replace front shoulder belt guide loop attachment nuts and install new guide cover.

1989 Buick Regal

Component

Exterior Lighting:Brake Lights:Switch

Consequence of Defect

Corrective Action

Recall Notes

install an improved design stoplamp switch.

1989 Buick Regal

Component

Fuel System, Gasoline:Storage:Tank Assembly:Filler Pipe And Cap

Consequence of Defect

fuel return lines could fracture and allow fuel to leak in the area of the fuel tank.

Corrective Action

in presence of an ignition source, this condition couldresult in a fire.

Recall Notes

install new fuel return pipe assembly.

1989 Buick Regal

Component

Fuel System, Gasoline

Consequence of Defect

Corrective Action

this condition may cause an inadequate seal at the connection, potentially leading to a fuel leak. in the presence of an ignition source, a fire could occur.

Recall Notes

honeywell will notify owners and replace the fuel filters free of charge. the recall began on october 18, 2006. owners may contact fram customer service at 1-800-890-2075 (option 1).

1989 Buick Regal

Component

Structure

Consequence of Defect

Corrective Action

if both bolts pull through, the front of the cradle would no longer be supported at the mounting locations and the steering intermediate shaft could separate from the steering gear.

Recall Notes

dealers will replace the front and rear frame/cradle bolts and retainers.

1989 Buick Regal

Component

Structure

Consequence of Defect

Corrective Action

if this were to occur while the vehicle was in motion, a vehicle crash could result.

Recall Notes

dealers will replace the rear cradle bolts and retainers.

1989 Buick Regal

Component

Wheels

Consequence of Defect

cracks develop in the wheel mounting surface. if these cracks become severe enough, the wheel will completely separate from the vehicle.

Corrective Action

if wheel separation occurs while the vehicle is in motion, loss of steering and brake control of the vehicle occurs, and a vehicle crash could result without prior warning.

Recall Notes

dealers will inspect the manufacturing date codes stamped on each wheel of the vehicle and if a wheel falls within the specified date code range, the dealer will replace that wheel assembly.

1989 Buick Regal

Component

Wheels

Consequence of Defect

cracks develop in the wheel mounting surface. if these cracks become severe enough, the wheel will completely separate from the vehicle.

Corrective Action

if wheel separation occurs while the vehicle is in motion, loss of steering and brake control of the vehicle occurs, and a vehicle crash could result without prior warning.

Recall Notes

dealers will inspect the manufacturing codes stamped on each wheel of the vehicle and if a wheel falls within the specified date code range, the dealer will replace that wheel assembly.

1989 Buick Regal

Component

Seat Belts

Consequence of Defect

front shoulder belt guide loop attachment fastener may pull through door mounted anchor plate.

Corrective Action

seat belt may not sustain loads required by fmvss 210, and in a vehicle accident, the seat belt may not properly restrain a passenger, resulting in increased risk of greater injury to an occupant.

Recall Notes

replace front shoulder belt guide loop attachment nuts and install new guide cover.

1988 Buick Regal

Component

Latches/Locks/Linkages:Hood:Latch

Consequence of Defect

the secondary hood latch may not properly engage.

Corrective Action

if primary latch disengages, hood could unexpectedlyopen. if car was in motion, hood could contact the windshield, reduce thedrivers forward vision area, and could result in an accident.

Recall Notes

replace secondary latch with a new latch.

1988 Buick Regal

Component

Service Brakes, Hydraulic:Foundation Components:Hoses, Lines/Piping, And Fittings

Consequence of Defect

twisted components could allow the left front brake hose to contact the fender lining/rail area; over time the brake hose could wear through.

Corrective Action

this could result in a loss of brake fluid and a partialloss of braking capability which could result in an accident.

Recall Notes

inspect left front brake hose for proper installation and replace, as necessary.

1988 Buick Regal

Component

Power Train:Manual Transmission:Column Shift Assembly

Consequence of Defect

an interference between the transmission shift cable and the bellcrank clip in the steering column can result in disengagement of the transmission cable.

Corrective Action

this condition could allow the transmission to be in agear other than that displayed by the shift indicator. the vehicle could movein an unexpected direction and cause a vehicle crash without prior warning.

Recall Notes

a newly designed bellcrank clip will be installed.

1988 Buick Regal

Component

Fuel System, Gasoline

Consequence of Defect

Corrective Action

this condition may cause an inadequate seal at the connection, potentially leading to a fuel leak. in the presence of an ignition source, a fire could occur.

Recall Notes

honeywell will notify owners and replace the fuel filters free of charge. the recall began on october 18, 2006. owners may contact fram customer service at 1-800-890-2075 (option 1).

1988 Buick Regal

Component

Structure

Consequence of Defect

Corrective Action

if both bolts pull through, the front of the cradle would no longer be supported at the mounting locations and the steering intermediate shaft could separate from the steering gear.

Recall Notes

dealers will replace the front and rear frame/cradle bolts and retainers.

1988 Buick Regal

Component

Structure

Consequence of Defect

Corrective Action

if this were to occur while the vehicle was in motion, a vehicle crash could result.

Recall Notes

dealers will replace the rear cradle bolts and retainers.

1988 Buick Regal

Component

Suspension:Front:Control Arm:Lower Ball Joint

Consequence of Defect

lower control arm to ball joint attachment can become loose. also, certain cars could have tie rod ball stud nuts that were not properly torqued and could loosen.

Corrective Action

continued operation of car with either condition couldresult in separation of that joint and possible loss of steering control and anaccident.

Recall Notes

replace both lower control arms; also, check tie rod ball stud nut torque.

1988 Buick Regal

Component

Exterior Lighting:Brake Lights:Switch

Consequence of Defect

the stop lamp switch may have a loose electrical contact. the loose contact can overheat and melt the surrounding plastic causing the contact to stick open.

Corrective Action

an open contact would render the brake lights inoperativewhen the brake pedal is depressed. also, the transmission clutch control andcruise control contacts would remain closed. this condition would result incruise resume upon brake pedal release if the cruise control is in the onposition. either an unexpected cruise resume or inoperative brake lights couldresult in a vehicle crash without prior warning.

Recall Notes

the rotary soplamp switch will be replaced on all involved vehicles.

1988 Buick Regal

Component

Wheels

Consequence of Defect

cracks develop in the wheel mounting surface. if these cracks become severe enough, the wheel will completely separate from the vehicle.

Corrective Action

if wheel separation occurs while the vehicle is in motion, loss of steering and brake control of the vehicle occurs, and a vehicle crash could result without prior warning.

Recall Notes

dealers will inspect the manufacturing date codes stamped on each wheel of the vehicle and if a wheel falls within the specified date code range, the dealer will replace that wheel assembly.

1988 Buick Regal

Component

Wheels

Consequence of Defect

cracks develop in the wheel mounting surface. if these cracks become severe enough, the wheel will completely separate from the vehicle.

Corrective Action

if wheel separation occurs while the vehicle is in motion, loss of steering and brake control of the vehicle occurs, and a vehicle crash could result without prior warning.

Recall Notes

dealers will inspect the manufacturing codes stamped on each wheel of the vehicle and if a wheel falls within the specified date code range, the dealer will replace that wheel assembly.

1988 Buick Regal

Component

Seat Belts

Consequence of Defect

front shoulder belt guide loop attachment fastener may pull through door mounted anchor plate.

Corrective Action

seat belt may not sustain loads required by fmvss 210, and in a vehicle accident, the seat belt may not properly restrain a passenger, resulting in increased risk of greater injury to an occupant.

Recall Notes

replace front shoulder belt guide loop attachment nuts and install new guide cover.

1987 Buick Regal

Component

Fuel System, Gasoline

Consequence of Defect

Corrective Action

this condition may cause an inadequate seal at the connection, potentially leading to a fuel leak. in the presence of an ignition source, a fire could occur.

Recall Notes

honeywell will notify owners and replace the fuel filters free of charge. the recall began on october 18, 2006. owners may contact fram customer service at 1-800-890-2075 (option 1).

1987 Buick Regal

Component

Vehicle Speed Control

Consequence of Defect

a small nylon bushing in the cruise control servo bail may slip out of place, causing intermittent and unexpected increases in engine speed or dieseling (engine run on with ignition off).

Corrective Action

servo rod assembly could catch on engine components andresult in a stuck throttle with potential for a vehicle crash.

Recall Notes

install a new bushing in cruise control servo bail.

1987 Buick Regal

Component

Power Train:Automatic Transmission:Lever And Linkage:Column Shift

Consequence of Defect

manual valve link in the transmission may have been improperly formed.

Corrective Action

the valve link could separate resulting in a gearselection different from what the driver selects. also, car could be startedwith transmission in gear allowing vehicle to move in an unanticipateddirection.

Recall Notes

replace the manual valve detent lever link.

1986 Buick Regal

Component

Fuel System, Gasoline

Consequence of Defect

Corrective Action

this condition may cause an inadequate seal at the connection, potentially leading to a fuel leak. in the presence of an ignition source, a fire could occur.

Recall Notes

honeywell will notify owners and replace the fuel filters free of charge. the recall began on october 18, 2006. owners may contact fram customer service at 1-800-890-2075 (option 1).

1986 Buick Regal

Component

Vehicle Speed Control

Consequence of Defect

a small nylon bushing in the cruise control servo bail may slip out of place, causing intermittent and unexpected increases in engine speed or dieseling (engine run on with ignition off).

Corrective Action

servo rod assembly could catch on engine components andresult in a stuck throttle with potential for a vehicle crash.

Recall Notes

install a new bushing in cruise control servo bail.

1986 Buick Regal

Component

Exterior Lighting:Headlights:Switch

Consequence of Defect

under extended headlamp usage, circuitry in the headlamp switch panel might experience increased resistance and excessive heat buildup.

Corrective Action

headlights would cycle on and off. sudden loss ofheadlights under severe weather or nightimer driving conditions could resultin a vehicle crash.

Recall Notes

replace headlight switch with modified switch.

1986 Buick Regal

Component

Structure

Consequence of Defect

small cracks may develop in the body pillar around the door striker bolt hole.

Corrective Action

cracks would increase leading to difficulty in closingthe door and might allow door to come open during a crash, increasinglikelihood of injury to occupants.

Recall Notes

install inner and outer reinforcement plate on both left and right body pillars.

1986 Buick Regal

Component

Seat Belts:Front:Anchorage

Consequence of Defect

left handed driver's side shoulder belt anchor plate may be upside down in lock pillar so that the unthreaded slot of the plate aligned with the hole in the lock pillar. this resulted in the anchor bolt being driven into the slot instead of the threaded hole of the anchor plate. consequence of defect: in a vehicle crash, belt anchor bolt may pull loose from anchor plate, thus failing to comply with fmvss 210, seat belt assembly anchorages, and increases likelihood of injury to occupant.

Corrective Action

Recall Notes

install a bolt anchor plate reinforcement and new bolt, as necessary.

1985 Buick Regal

Component

Vehicle Speed Control:Springs

Consequence of Defect

the throttle return spring assembly may fail preventing the throttle from returning to the closed (idle) position when the accelerator pedal is released. consequence of defect: engine speed may not decrease and loss of accelerator control could result in an accident without prior warning.

Corrective Action

Recall Notes

replace throttle return spring.

1985 Buick Regal

Component

Seat Belts:Front:Retractor

Consequence of Defect

the vehicles were assembled with front seat belt retractors which may not perform adequately during a collision.

Corrective Action

Recall Notes

the dealer will replace the left and right front seat belt retractors free of charge.

1985 Buick Regal

Component

Steering:Linkages:Tie Rod Assembly

Consequence of Defect

the tie rods are part of the steering linkage and transmit turning movements to the wheels. the bolts that fasten the tie rods to their adjusters may not be tight enough. this could allow the tie rod to loosen and detach itself from the adjuster.

Corrective Action

Recall Notes

the tie rod end bolts will be tightened without cost to the owner.

1985 Buick Regal

Component

Visibility:Windshield

Consequence of Defect

a loss of bonding adhesion between the paint and the windshield opening area could allow the windshield to separate during a 30 mile per hour frontal barrier test required by fmvss 212, windshield retention. consequence of defect: windshield separation during an accident could result in an unbelted occupant being ejected from the car and severly injured.

Corrective Action

Recall Notes

remove and reinstall windshield if a lack of paint bonding is evident.

1985 Buick Regal

Component

Fuel System, Gasoline

Consequence of Defect

Corrective Action

this condition may cause an inadequate seal at the connection, potentially leading to a fuel leak. in the presence of an ignition source, a fire could occur.

Recall Notes

honeywell will notify owners and replace the fuel filters free of charge. the recall began on october 18, 2006. owners may contact fram customer service at 1-800-890-2075 (option 1).

1985 Buick Regal

Component

Structure:Body:Bumpers

Consequence of Defect

the rear bumper may fracture during a rear end collision, puncture the fuel tank, and cause a fuel leak. consequence of defect: a fuel leak creates the potential for a fire which could result in burn injuries to persons in or near the car.

Corrective Action

Recall Notes

replace the rear bumper brackets and the "l" shaped reinforcement with a "u" shaped full reinforcement.

1985 Buick Regal

Component

Exterior Lighting:Headlights:Switch

Consequence of Defect

under extended headlamp usage, circuitry in the headlamp switch panel might experience increased resistance and excessive heat buildup.

Corrective Action

headlights would cycle on and off. sudden loss ofheadlights under severe weather or nightimer driving conditions could resultin a vehicle crash.

Recall Notes

replace headlight switch with modified switch.

1985 Buick Regal

Component

Structure

Consequence of Defect

small cracks may develop in the body pillar around the door striker bolt hole.

Corrective Action

cracks would increase leading to difficulty in closingthe door and might allow door to come open during a crash, increasinglikelihood of injury to occupants.

Recall Notes

install inner and outer reinforcement plate on both left and right body pillars.

1985 Buick Regal

Component

Equipment:Other:Labels

Consequence of Defect

the certification label located on the left front door did not include a required federal certification statement. consequence of defect: vehicles do not comply with federal regulation 567.

Corrective Action

Recall Notes

labels containing correct information are being mailed and should be installed on the left front door.

1984 Buick Regal

Component

Fuel System, Gasoline

Consequence of Defect

Corrective Action

this condition may cause an inadequate seal at the connection, potentially leading to a fuel leak. in the presence of an ignition source, a fire could occur.

Recall Notes

honeywell will notify owners and replace the fuel filters free of charge. the recall began on october 18, 2006. owners may contact fram customer service at 1-800-890-2075 (option 1).

1984 Buick Regal

Component

Structure:Body:Bumpers

Consequence of Defect

Corrective Action

Recall Notes

replace the rear bumper brackets and the "l" shaped reinforcement with a "u" shaped full reinforcement.

1984 Buick Regal

Component

Vehicle Speed Control

Consequence of Defect

a small nylon bushing in the cruise control servo bail may slip out of place, causing intermittent and unexpected increases in engine speed or dieseling (engine run on with ignition off).

Corrective Action

servo rod assembly could catch on engine components andresult in a stuck throttle with potential for a vehicle crash.

Recall Notes

install a new bushing in cruise control servo bail.

1984 Buick Regal

Component

Steering:Gear Box (Other Than Rack And Pinion)

Consequence of Defect

one of the three steering gear to frame bolts may not have been tightened to the required specification. consequence of defect: the steering gear could come loose from the frame causing a loss of steering control and a possible vehicle crash without warning.

Corrective Action

Recall Notes

tighten the steering gear to frame bolts.

1984 Buick Regal

Component

Seats:Front Assembly:Recliner

Consequence of Defect

some vehicles have bucket seat back locks that do not conform to federal motor vehicle safety standard 207, anchorage of seats. in event of a crash, the seat back lock may not function.

Corrective Action

Recall Notes

inspection of seat back locks will be performed. locks that have bent, broken or missing hooks will be replaced.

1983 Buick Regal

Component

Service Brakes, Hydraulic:Foundation Components:Hoses, Lines/Piping, And Fittings

Consequence of Defect

the master cylinder rear brake pipe, which carries brake fluid to the rear brakes, may develop a leak due to extended chafing on the air cleaner resonator bracket.

Corrective Action

Recall Notes

if upon inspection the dealer finds that there is inadequate clearance, the pipe will be reformed to obtain the necessary three quarter inch space. only those pipes showing signs of wear will be replaced.

1982 Buick Regal

Component

Fuel System, Gasoline:Fuel Injection System

Consequence of Defect

under certain vehicle operating conditions, the governor weight retainer in the injection pump may fail. the throttle valve could stick, preventing return to idle and shut down of the engine by the driver.

Corrective Action

Recall Notes

dealer will replace the governor weight assembly in the injection pump at no cost to owner.

1982 Buick Regal

Component

Fuel System, Gasoline:Fuel Injection System:Fuel Rail

Consequence of Defect

the fuel inlet pipe may develop cracks at the flared end leading into the carburetor due to vibrations in operation. these cracks could result in fuel leakage.

Corrective Action

Recall Notes

dealer will install a new fuel inlet pipe on the involved vehicles, free of charge.

1981 Buick Regal

Component

Wheels

Consequence of Defect

the steel used in some compact spare wheels is too thin. while in service the wheel may fracture, resulting in a partial or complete separation of the wheel and tire from the vehicle.

Corrective Action

Recall Notes

spare wheels will be replaced without charge to owners within 60 days of recall notification.

1981 Buick Regal

Component

Wheels:Center Section

Consequence of Defect

"tx" heavy duty wheels may have been manufactured with laminated steel. the wheel disc may fracture and the wheel and tire could partially or completely separate from the vehicle.

Corrective Action

Recall Notes

the defective wheels will be replaced without charge.

1981 Buick Regal

Component

Suspension:Rear

Consequence of Defect

the bolts that attach the lower rear control arm to the frame may fracture. the rear control arm supports and positions the rear axle. fracture of the bolts would allow the control arm to drop free.

Corrective Action

Recall Notes

both rear control arm attachment bolts will be replaced without charge.

1980 Buick Regal

Component

Suspension:Rear

Consequence of Defect

the bolts that attached the rear suspension control arms to the frame and axle may be defective and the bolt head may separate from the bolt shank. this could allow the control arm to come loose.

Corrective Action

Recall Notes

the dealer will replace all suspect rear suspension control arm bolts prior to delivery. this will be done free of charge.

1980 Buick Regal

Component

Suspension:Rear

Consequence of Defect

the bolts that attach the lower rear control arm to the frame may fracture. the rear control arm supports and positions the rear axle. fracture of the bolts would allow the control arm to drop free.

Corrective Action

Recall Notes

both rear control arm attachment bolts will be replaced without charge.

1980 Buick Regal

Component

Exterior Lighting:Turn Signal

Consequence of Defect

the involved vehicles may have been assembled with clear lamp bulbs instead of the correct amber bulbs in front park and turn signal locations. as a result, these vehicles do not conform to federal motor vehicle safety standard no. 108, "lamps, reflective devices and associated equipment".

Corrective Action

Recall Notes

dealer will inspect and, if necessary, replace clear park and turn signal lamp bulbs with amber bulbs at no cost to owner.

1980 Buick Regal

Component

Service Brakes, Hydraulic:Foundation Components:Drum:Wheel Cylinders

Consequence of Defect

excessive enlargement of the wheel cylinder pilot hole in the rear brake backing plate could allow the wheel cylinder to rotate and cause loss of brake fluid. consequence of defect: a loss of brake fluid leads to loss of rear brake action, creating the potential for an accident. front brakes would remain operational.

Corrective Action

Recall Notes

add a part to prevent wheel cylinder from rotating.

1980 Buick Regal

Component

Equipment

Consequence of Defect

certain honeywell fram racing brand hp4 and hp8 oil filters that were manufactured from may 25, 2006, through september 14, 2007, and sold for use as replacement equipment for vehicles list above. the affected filters are marked with a date code a61451 through a72571 sequentially. the date code and part number appear on the filter housing. fram racing hp4 and hp8 oil filters not bearing a date code in this range are not affected by this recall. the gasket of the oil filter becomes more pliable under high temperatures and pressures.

Corrective Action

this condition may cause inadequate sealing and loss of engine oil, possibly resulting in a fire.

Recall Notes

honeywell will replace the affected oil filters free of charge. the recall began during november 2007. owners can contact fram customer service toll-free at 1-800-890-2075.

1980 Buick Regal

Component

Power Train:Axle Assembly:Axle Shaft

Consequence of Defect

rear axle assembly may have axles that were improperly manufactured. this condition may result in separation of the axle shaft and wheel assembly from the vehicle.

Corrective Action

Recall Notes

the dealer will inspect the rear axle to determine whether it was manufactured at the buffalo plant. if so, they will make axle measurements and if necessary replace or modify affected axle components without charge.

1979 Buick Regal

Component

Suspension:Rear

Consequence of Defect

the bolts that attach the lower rear control arm to the frame may fracture. the rear control arm supports and positions the rear axle. fracture of the bolts would allow the control arm to drop free.

Corrective Action

Recall Notes

both rear control arm attachment bolts will be replaced without charge.

1979 Buick Regal

Component

Power Train:Automatic Transmission:Lever And Linkage:Floor Shift

Consequence of Defect

the shift cable retaining clip may have been installed backwards or not at all. the purpose of this spring clip is to secure the lower end of the shift cable housing to the transmission. if the clip is backward or missing, the console shift lever may not shift the transmission and/or the transmission range indicator may indicate that the transmission is in the "park" or "p" position when it is not.

Corrective Action

Recall Notes

the dealer will inspect and if necessary correct the shift cable retaining clip installation at no charge.

1979 Buick Regal

Component

Equipment

Consequence of Defect

Corrective Action

this condition may cause inadequate sealing and loss of engine oil, possibly resulting in a fire.

Recall Notes

honeywell will replace the affected oil filters free of charge. the recall began during november 2007. owners can contact fram customer service toll-free at 1-800-890-2075.

1979 Buick Regal

Component

Power Train:Axle Assembly:Axle Shaft

Consequence of Defect

rear axle assembly may have axles that were improperly manufactured. this condition may result in separation of the axle shaft and wheel assembly from the vehicle.

Corrective Action

Recall Notes

1979 Buick Regal

Component

Exterior Lighting:Brake Lights:Switch

Consequence of Defect

on the involved vehicles the brake stoplight and cruise control switch which is operated by the brake pedal may have been assembled with an incorrect lubricant on the actuating plunger. this can cause the rear brake stoplights to become inoperative and the cruise control, if activated, to stay electrically engaged.

Corrective Action

Recall Notes

dealer will inspect and, if necessary, replace the brake stoplight and cruise control switch at no cost to owner.

1978 Buick Regal

Component

Engine And Engine Cooling:Cooling System:Fan

Consequence of Defect

the hub portion of the fan blade assembly could crack due to high stress levels generated during engine operating conditions. eventually, the blade could break apart at the hub and blade pieces could be propelled into the engine. if the hood is open while the engine is running, the fragments would be free to fly from the vehicle.

Corrective Action

Recall Notes

dealer will replace the fan blade assembly without charge to owner.

1978 Buick Regal

Component

Equipment:Other:Labels

Consequence of Defect

the involved vehicles do not conform to federal motor vehicle safety standard no. 110, "tire selection and rims", in that the tire placard does not contain legible tire size information.

Corrective Action

Recall Notes

dealer will provide proper labels for the owner to install, or for dealer installation, if preferred.

1978 Buick Regal

Component

Suspension:Front:Wheel Bearing

Consequence of Defect

under certain driving conditions, these vehicles can experience temperatures in the front wheel outer bearing area which can affect the wheel bearing grease. this can result in inadequate lubrication of the bearing. this condition may be further aggravated by improper adjustment of the front wheel spindle nut.

Corrective Action

Recall Notes

the dealer will install new front wheel outer bearings packed with grease and the spindle will be coated with lubricant. new grease retainer caps will also be installed to maintain grease in outer bearing. this will be done free of charge.

1978 Buick Regal

Component

Suspension:Rear

Consequence of Defect

the bolts that attach the lower rear control arm to the frame may fracture. the rear control arm supports and positions the rear axle. fracture of the bolts would allow the control arm to drop free.

Corrective Action

Recall Notes

both rear control arm attachment bolts will be replaced without charge.

1978 Buick Regal

Component

Service Brakes, Hydraulic:Foundation Components:Drum:Wheel Cylinders

Consequence of Defect

Corrective Action

Recall Notes

add a part to prevent wheel cylinder from rotating.

1978 Buick Regal

Component

Equipment

Consequence of Defect

Corrective Action

this condition may cause inadequate sealing and loss of engine oil, possibly resulting in a fire.

Recall Notes

honeywell will replace the affected oil filters free of charge. the recall began during november 2007. owners can contact fram customer service toll-free at 1-800-890-2075.

1978 Buick Regal

Component

Power Train:Axle Assembly:Axle Shaft

Consequence of Defect

rear axle assembly may have axles that were improperly manufactured. this condition may result in separation of the axle shaft and wheel assembly from the vehicle.

Corrective Action

Recall Notes

1977 Buick Regal

Component

Power Train:Axle Assembly:Axle Shaft

Consequence of Defect

the rear axle shafts may contain a flaw in the metal. this flaw could allow the shaft to break and the tire and wheel assembly to separate.

Corrective Action

Recall Notes

the dealer will replace one or both rear axle shafts, if necessary, free of charge.

1977 Buick Regal

Component

Steering:Wheel And Handle Bar

Consequence of Defect

Corrective Action

Recall Notes

1977 Buick Regal

Component

Electrical System:Wiring:Front Underhood

Consequence of Defect

Corrective Action

Recall Notes

1977 Buick Regal

Component

Equipment

Consequence of Defect

Corrective Action

this condition may cause inadequate sealing and loss of engine oil, possibly resulting in a fire.

Recall Notes

honeywell will replace the affected oil filters free of charge. the recall began during november 2007. owners can contact fram customer service toll-free at 1-800-890-2075.