Lemon Law Center

Home > Beaver

2002 Beaver Patriot Thunder

Component

Vehicle Speed Control:Accelerator Pedal

Consequence of Defect

on certain motor homes equipped with electronic throttle control/accelerator pedals supplied by williams controls industries, the weld attaching the clevis to the plate has insufficient penetration and could allow the clevis to separate from the plate.

Corrective Action

if the clevis separated from the plate while the vehicle was in use, the vehicle would return to idle, increasing the risk of a crash.

Recall Notes

dealers will replace these pedals. owner notification began september 9, 2002. owners who do not receive the free remedy within a reasonable time should contact monaco at 1-800-344-6332 or williams control at 1-503-684-8600.

2001 Beaver Patriot Thunder

Component

Equipment:Recreational Vehicle

Consequence of Defect

on certain motor homes, fifth wheel and travel trailers equipped with a two-door refrigerator manufactured by the dometic corporation, the refrigerator may have a defect in the boiler tube. pressurized coolant solution could be released into an area where an ignition source (gas flame) is present.

Corrective Action

release of coolant under certain conditions could ignite and result in a fire.

Recall Notes

monaco will be working with dometic in order to repair these refrigerators (please see 06e076). dometic will repair these refrigerators by installing a secondary burn housing, a thermal fuse, and a melt fuse free of charge. dometic has retained stericycle inc. to manage this campaign. stericycle will assist the owner in locating dealerships or service centers and will provide assistance with scheduling of appointments. owners may contact dometic at 1-888-446-5157, stericycle at 1-317-860-1163, or monaco at 1-877-466-6226.

2001 Beaver Patriot Thunder

Component

Service Brakes, Hydraulic:Foundation Components

Consequence of Defect

on certain motor homes, the brake assemblies exhibit elevated temperatures that can lead to catastrophic deterioration of the wheel end components such as bearings, races, spindles, knuckles, seals, hubs, rotors, patch bolts, calipers, brake pads, and abs sensors.

Corrective Action

this could result in loss of control, and/or the potential for a fire.

Recall Notes

dealers will inspect the front and rear brake calipers for corrosion and replace or rebuild the calipers as necessary. the recall began on august 18, 2004. owners should contact monaco at 1-800-685-6545.

2000 Beaver Patriot Thunder

Component

Equipment:Recreational Vehicle

Consequence of Defect

on certain motor homes, fifth wheel and travel trailers equipped with a two-door refrigerator manufactured by the dometic corporation, the refrigerator may have a defect in the boiler tube. pressurized coolant solution could be released into an area where an ignition source (gas flame) is present.

Corrective Action

release of coolant under certain conditions could ignite and result in a fire.

Recall Notes

monaco will be working with dometic in order to repair these refrigerators (please see 06e076). dometic will repair these refrigerators by installing a secondary burn housing, a thermal fuse, and a melt fuse free of charge. dometic has retained stericycle inc. to manage this campaign. stericycle will assist the owner in locating dealerships or service centers and will provide assistance with scheduling of appointments. owners may contact dometic at 1-888-446-5157, stericycle at 1-317-860-1163, or monaco at 1-877-466-6226.

2000 Beaver Patriot Thunder

Component

Service Brakes, Hydraulic:Foundation Components

Consequence of Defect

on certain motor homes, the brake assemblies exhibit elevated temperatures that can lead to catastrophic deterioration of the wheel end components such as bearings, races, spindles, knuckles, seals, hubs, rotors, patch bolts, calipers, brake pads, and abs sensors.

Corrective Action

this could result in loss of control, and/or the potential for a fire.

Recall Notes

dealers will inspect the front and rear brake calipers for corrosion and replace or rebuild the calipers as necessary. the recall began on august 18, 2004. owners should contact monaco at 1-800-685-6545.

1999 Beaver Patriot Thunder

Component

Equipment:Recreational Vehicle

Consequence of Defect

on certain motor homes, fifth wheel and travel trailers equipped with a two-door refrigerator manufactured by the dometic corporation, the refrigerator may have a defect in the boiler tube. pressurized coolant solution could be released into an area where an ignition source (gas flame) is present.

Corrective Action

release of coolant under certain conditions could ignite and result in a fire.

Recall Notes

monaco will be working with dometic in order to repair these refrigerators (please see 06e076). dometic will repair these refrigerators by installing a secondary burn housing, a thermal fuse, and a melt fuse free of charge. dometic has retained stericycle inc. to manage this campaign. stericycle will assist the owner in locating dealerships or service centers and will provide assistance with scheduling of appointments. owners may contact dometic at 1-888-446-5157, stericycle at 1-317-860-1163, or monaco at 1-877-466-6226.

1999 Beaver Patriot Thunder

Component

Equipment:Recreational Vehicle

Consequence of Defect

on certain motorhomes, fifth wheels and travel trailers equipped with norcold refrigerator cooling units model numbers 1200lr and 1200rim, these refrigerators can experience low cycle fatigue failure which can lead to the liquid solution slowly leaking from the sealed, pressurized cooling unit through a small crack.

Corrective Action

if a leak occurs and the unit is continually operated, hydrogen gas may be expelled and can be ignited, resulting in a fire, possibly causing serious injury or death.

Recall Notes

norcold will notify its customers and provide a replacement cooling unit free of charge. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact norcold service center at 1-800-667-3005 or monaco at 574-862-7211.

1999 Beaver Patriot Thunder

Component

Service Brakes, Hydraulic:Foundation Components

Consequence of Defect

on certain motor homes, the brake assemblies exhibit elevated temperatures that can lead to catastrophic deterioration of the wheel end components such as bearings, races, spindles, knuckles, seals, hubs, rotors, patch bolts, calipers, brake pads, and abs sensors.

Corrective Action

this could result in loss of control, and/or the potential for a fire.

Recall Notes

dealers will inspect the front and rear brake calipers for corrosion and replace or rebuild the calipers as necessary. the recall began on august 18, 2004. owners should contact monaco at 1-800-685-6545.

1998 Beaver Patriot Thunder

Component

Equipment:Recreational Vehicle

Consequence of Defect

on certain motorhomes, fifth wheels and travel trailers equipped with norcold refrigerator cooling units model numbers 1200lr and 1200rim, these refrigerators can experience low cycle fatigue failure which can lead to the liquid solution slowly leaking from the sealed, pressurized cooling unit through a small crack.

Corrective Action

if a leak occurs and the unit is continually operated, hydrogen gas may be expelled and can be ignited, resulting in a fire, possibly causing serious injury or death.

Recall Notes

norcold will notify its customers and provide a replacement cooling unit free of charge. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact norcold service center at 1-800-667-3005 or monaco at 574-862-7211.

1998 Beaver Patriot Thunder

Component

Service Brakes, Hydraulic:Foundation Components

Consequence of Defect

on certain motor homes, the brake assemblies exhibit elevated temperatures that can lead to catastrophic deterioration of the wheel end components such as bearings, races, spindles, knuckles, seals, hubs, rotors, patch bolts, calipers, brake pads, and abs sensors.

Corrective Action

this could result in loss of control, and/or the potential for a fire.

Recall Notes

dealers will inspect the front and rear brake calipers for corrosion and replace or rebuild the calipers as necessary. the recall began on august 18, 2004. owners should contact monaco at 1-800-685-6545.