Home > Am General

2001 Am General Hummer

Component

Equipment

Consequence of Defect

certain honeywell fram racing brand hp4 and hp8 oil filters that were manufactured from may 25, 2006, through september 14, 2007, and sold for use as replacement equipment for vehicles list above. the affected filters are marked with a date code a61451 through a72571 sequentially. the date code and part number appear on the filter housing. fram racing hp4 and hp8 oil filters not bearing a date code in this range are not affected by this recall. the gasket of the oil filter becomes more pliable under high temperatures and pressures.

Corrective Action

this condition may cause inadequate sealing and loss of engine oil, possibly resulting in a fire.

Recall Notes

honeywell will replace the affected oil filters free of charge. the recall began during november 2007. owners can contact fram customer service toll-free at 1-800-890-2075.

2000 Am General Hummer

Component

Service Brakes, Hydraulic:Foundation Components:Hoses, Lines/Piping, And Fittings

Consequence of Defect

vehicle description: a potential chafing condition occurs between the flexible brake lines which connect the master cylinder to the abs modulator. this condition can lead to one or both of the brake lines developing a brake fluid leak.

Corrective Action

a brake fluid leak cab cause a reduction in brake line pressure and resulting in longer-than-normal stopping distances.

Recall Notes

dealers will replace the master cylinder to abs modulator lines.

2000 Am General Hummer

Component

Exterior Lighting:Turn Signal:Switch

Consequence of Defect

vehicle description: sport utility vehicles. the turn signal switch plastic cancellation pin can wear prematurely causing the signals to fail to cancel after completing a turn.

Corrective Action

this could send an incorrect lamp signal to other vehicles, increasing the risk of a crash.

Recall Notes

dealers will replace the turn signal switch with a new switch having a metal cancellation pin. owner notification began november 16, 2001. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact am general at 1-800-638-8303.

2000 Am General Hummer

Component

Equipment

Consequence of Defect

certain honeywell fram racing brand hp4 and hp8 oil filters that were manufactured from may 25, 2006, through september 14, 2007, and sold for use as replacement equipment for vehicles list above. the affected filters are marked with a date code a61451 through a72571 sequentially. the date code and part number appear on the filter housing. fram racing hp4 and hp8 oil filters not bearing a date code in this range are not affected by this recall. the gasket of the oil filter becomes more pliable under high temperatures and pressures.

Corrective Action

this condition may cause inadequate sealing and loss of engine oil, possibly resulting in a fire.

Recall Notes

honeywell will replace the affected oil filters free of charge. the recall began during november 2007. owners can contact fram customer service toll-free at 1-800-890-2075.

1999 Am General Hummer

Component

Service Brakes, Hydraulic:Power Assist

Consequence of Defect

vehicle description: sport utility vehicles. the nuts used to attach the master cylinder to the hydroboost bolts were of the metric type rather than the required english type.

Corrective Action

a loose master cylinder condition can occur, causing longer than normal brake pedal travel during brake pedal applications.

Recall Notes

dealers will replace the master cylinder-to-hydroboost mounting bolts and nuts.

1999 Am General Hummer

Component

Service Brakes, Hydraulic:Foundation Components:Hoses, Lines/Piping, And Fittings

Consequence of Defect

vehicle description: a potential chafing condition occurs between the flexible brake lines which connect the master cylinder to the abs modulator. this condition can lead to one or both of the brake lines developing a brake fluid leak.

Corrective Action

a brake fluid leak cab cause a reduction in brake line pressure and resulting in longer-than-normal stopping distances.

Recall Notes

dealers will replace the master cylinder to abs modulator lines.

1999 Am General Hummer

Component

Exterior Lighting:Turn Signal:Switch

Consequence of Defect

vehicle description: sport utility vehicles. the turn signal switch plastic cancellation pin can wear prematurely causing the signals to fail to cancel after completing a turn.

Corrective Action

this could send an incorrect lamp signal to other vehicles, increasing the risk of a crash.

Recall Notes

dealers will replace the turn signal switch with a new switch having a metal cancellation pin. owner notification began november 16, 2001. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact am general at 1-800-638-8303.

1999 Am General Hummer

Component

Equipment

Consequence of Defect

certain honeywell fram racing brand hp4 and hp8 oil filters that were manufactured from may 25, 2006, through september 14, 2007, and sold for use as replacement equipment for vehicles list above. the affected filters are marked with a date code a61451 through a72571 sequentially. the date code and part number appear on the filter housing. fram racing hp4 and hp8 oil filters not bearing a date code in this range are not affected by this recall. the gasket of the oil filter becomes more pliable under high temperatures and pressures.

Corrective Action

this condition may cause inadequate sealing and loss of engine oil, possibly resulting in a fire.

Recall Notes

honeywell will replace the affected oil filters free of charge. the recall began during november 2007. owners can contact fram customer service toll-free at 1-800-890-2075.

1998 Am General Hummer

Component

Exterior Lighting:Turn Signal:Switch

Consequence of Defect

vehicle description: sport utility vehicles. the turn signal switch plastic cancellation pin can wear prematurely causing the signals to fail to cancel after completing a turn.

Corrective Action

this could send an incorrect lamp signal to other vehicles, increasing the risk of a crash.

Recall Notes

dealers will replace the turn signal switch with a new switch having a metal cancellation pin. owner notification began november 16, 2001. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact am general at 1-800-638-8303.

1998 Am General Hummer

Component

Equipment

Consequence of Defect

certain honeywell fram racing brand hp4 and hp8 oil filters that were manufactured from may 25, 2006, through september 14, 2007, and sold for use as replacement equipment for vehicles list above. the affected filters are marked with a date code a61451 through a72571 sequentially. the date code and part number appear on the filter housing. fram racing hp4 and hp8 oil filters not bearing a date code in this range are not affected by this recall. the gasket of the oil filter becomes more pliable under high temperatures and pressures.

Corrective Action

this condition may cause inadequate sealing and loss of engine oil, possibly resulting in a fire.

Recall Notes

honeywell will replace the affected oil filters free of charge. the recall began during november 2007. owners can contact fram customer service toll-free at 1-800-890-2075.

1997 Am General Hummer

Component

Equipment

Consequence of Defect

certain honeywell fram racing brand hp4 and hp8 oil filters that were manufactured from may 25, 2006, through september 14, 2007, and sold for use as replacement equipment for vehicles list above. the affected filters are marked with a date code a61451 through a72571 sequentially. the date code and part number appear on the filter housing. fram racing hp4 and hp8 oil filters not bearing a date code in this range are not affected by this recall. the gasket of the oil filter becomes more pliable under high temperatures and pressures.

Corrective Action

this condition may cause inadequate sealing and loss of engine oil, possibly resulting in a fire.

Recall Notes

honeywell will replace the affected oil filters free of charge. the recall began during november 2007. owners can contact fram customer service toll-free at 1-800-890-2075.

1996 Am General Hummer

Component

Vehicle Speed Control:Accelerator Pedal

Consequence of Defect

the coating used to protect the accelerator pedal shaft is incompatible with the bronze bushing through which the shaft passes. over time, and in the presence of a corrosive environment (water, road salt), the shaft can corrode inside the bushing increasing the amount of friction between the rotating shaft and the stationary bushing.

Corrective Action

a corroded accelerator pedal shaft can cause the engine throttle to bind and not fully return to idle when the operator's foot is removed from the accelerator pedal increasing the potential for a vehicle accident.

Recall Notes

dealers will install a revised accelerator pedal and shaft assembly.

1996 Am General Hummer

Component

Seats

Consequence of Defect

vehicle description: buses equipped with isringhausen seats in the driver position. two welds located on the back rest adjustment side of the seat frame did not meet the manufacturer's specifications.

Corrective Action

if these welds were not to specification, back rest loads could cause the welds to fail. the back rest would disengage from the seat frame allowing loss of support to the driver's torso and possibly causing loss of control of the vehicle.

Recall Notes

isringhausen is conducting the owner notification and remedy campaign for this recall. dealers will inspect these seats and replace the seat frame assembly.

1996 Am General Hummer

Component

Fuel System, Gasoline

Consequence of Defect

certain replacement fuel filters, fram brand name p/n g3727, with date codes x52911 through x60801 sequentially or x600141 and a mexico country or origin marking on the fuel filter housing manufactured from october 18, 2005, through march 21, 2006, sold for use on the vehicles listed above and on certain school buses. (to see the school bus engine sizes, click on "document search" and then "bus applications"). the connector on the fuel filter was not manufactured to honeywell's specification. as a result, the o-ring may not seat correctly on the fuel line.

Corrective Action

this condition may cause an inadequate seal at the connection, potentially leading to a fuel leak. in the presence of an ignition source, a fire could occur.

Recall Notes

honeywell will notify owners and replace the fuel filters free of charge. the recall began on october 18, 2006. owners may contact fram customer service at 1-800-890-2075 (option 1).

1996 Am General Hummer

Component

Equipment

Consequence of Defect

certain honeywell fram racing brand hp4 and hp8 oil filters that were manufactured from may 25, 2006, through september 14, 2007, and sold for use as replacement equipment for vehicles list above. the affected filters are marked with a date code a61451 through a72571 sequentially. the date code and part number appear on the filter housing. fram racing hp4 and hp8 oil filters not bearing a date code in this range are not affected by this recall. the gasket of the oil filter becomes more pliable under high temperatures and pressures.

Corrective Action

this condition may cause inadequate sealing and loss of engine oil, possibly resulting in a fire.

Recall Notes

honeywell will replace the affected oil filters free of charge. the recall began during november 2007. owners can contact fram customer service toll-free at 1-800-890-2075.

1995 Am General Hummer

Component

Vehicle Speed Control:Accelerator Pedal

Consequence of Defect

the coating used to protect the accelerator pedal shaft is incompatible with the bronze bushing through which the shaft passes. over time, and in the presence of a corrosive environment (water, road salt), the shaft can corrode inside the bushing increasing the amount of friction between the rotating shaft and the stationary bushing.

Corrective Action

a corroded accelerator pedal shaft can cause the engine throttle to bind and not fully return to idle when the operator's foot is removed from the accelerator pedal increasing the potential for a vehicle accident.

Recall Notes

dealers will install a revised accelerator pedal and shaft assembly.

1995 Am General Hummer

Component

Vehicle Speed Control

Consequence of Defect

water can accumulate in the cruise control cable and if the outside temperature is below freezing and the cruise control is engaged, the water can freeze causing the cable to bind and not release as intended when the brake pedal is applied or the system is turned off at the master cruise control switch.

Corrective Action

the engine throttle can stick open resulting in loss of throttle control with the increased potential for a vehicle accident.

Recall Notes

dealers will remove the current cruise control actuator and cable assembly and install a new assembly. additionally, dealers will change the routing of the cable.

1995 Am General Hummer

Component

Fuel System, Gasoline

Consequence of Defect

certain replacement fuel filters, fram brand name p/n g3727, with date codes x52911 through x60801 sequentially or x600141 and a mexico country or origin marking on the fuel filter housing manufactured from october 18, 2005, through march 21, 2006, sold for use on the vehicles listed above and on certain school buses. (to see the school bus engine sizes, click on "document search" and then "bus applications"). the connector on the fuel filter was not manufactured to honeywell's specification. as a result, the o-ring may not seat correctly on the fuel line.

Corrective Action

this condition may cause an inadequate seal at the connection, potentially leading to a fuel leak. in the presence of an ignition source, a fire could occur.

Recall Notes

honeywell will notify owners and replace the fuel filters free of charge. the recall began on october 18, 2006. owners may contact fram customer service at 1-800-890-2075 (option 1).

1995 Am General Hummer

Component

Fuel System, Gasoline:Storage:Tank Assembly

Consequence of Defect

under high ambient temperatures (greater than 95 degrees fahrenheit) and the fuel tank level between 1/4 and 1/2 full, the fuel tank internal pressure can increase causing the tank to expand. tank expansion causes an interference between the fuel tank protective shield and the propeller shaft resulting a hole in the fuel tank at the point of shield-to-shaft contact.

Corrective Action

this condition can cause fuel leakage, and if an ignition source is present, could result in a fire.

Recall Notes

dealers will install a supplemental fuel tank venting system on these vehicles.

1995 Am General Hummer

Component

Equipment

Consequence of Defect

certain honeywell fram racing brand hp4 and hp8 oil filters that were manufactured from may 25, 2006, through september 14, 2007, and sold for use as replacement equipment for vehicles list above. the affected filters are marked with a date code a61451 through a72571 sequentially. the date code and part number appear on the filter housing. fram racing hp4 and hp8 oil filters not bearing a date code in this range are not affected by this recall. the gasket of the oil filter becomes more pliable under high temperatures and pressures.

Corrective Action

this condition may cause inadequate sealing and loss of engine oil, possibly resulting in a fire.

Recall Notes

honeywell will replace the affected oil filters free of charge. the recall began during november 2007. owners can contact fram customer service toll-free at 1-800-890-2075.

1994 Am General Hummer

Component

Vehicle Speed Control:Accelerator Pedal

Consequence of Defect

the coating used to protect the accelerator pedal shaft is incompatible with the bronze bushing through which the shaft passes. over time, and in the presence of a corrosive environment (water, road salt), the shaft can corrode inside the bushing increasing the amount of friction between the rotating shaft and the stationary bushing.

Corrective Action

a corroded accelerator pedal shaft can cause the engine throttle to bind and not fully return to idle when the operator's foot is removed from the accelerator pedal increasing the potential for a vehicle accident.

Recall Notes

dealers will install a revised accelerator pedal and shaft assembly.

1994 Am General Hummer

Component

Vehicle Speed Control

Consequence of Defect

water can accumulate in the cruise control cable and if the outside temperature is below freezing and the cruise control is engaged, the water can freeze causing the cable to bind and not release as intended when the brake pedal is applied or the system is turned off at the master cruise control switch.

Corrective Action

the engine throttle can stick open resulting in loss of throttle control with the increased potential for a vehicle accident.

Recall Notes

dealers will remove the current cruise control actuator and cable assembly and install a new assembly. additionally, dealers will change the routing of the cable.

1994 Am General Hummer

Component

Fuel System, Gasoline:Delivery:Hoses, Lines/Piping, And Fittings

Consequence of Defect

the oil pressure switch which controls the power to the electric fuel pump can fail. failure is due to a missing rubber seal between the switch and the wiring harness. the missing seal allows contaminants to enter the switch causing it to fail in the open or closed position.

Corrective Action

if the switch fails in the closed position, the pump will continue to run when the engine is off, draining the battery. if the switch fails in the open position it will cause poor performance and possibly stalling.

Recall Notes

dealers will inspect the vehicles for the presence of the seal. if the seal is missing, the switch will be replaced and a new seal will be installed.

1994 Am General Hummer

Component

Equipment

Consequence of Defect

certain honeywell fram racing brand hp4 and hp8 oil filters that were manufactured from may 25, 2006, through september 14, 2007, and sold for use as replacement equipment for vehicles list above. the affected filters are marked with a date code a61451 through a72571 sequentially. the date code and part number appear on the filter housing. fram racing hp4 and hp8 oil filters not bearing a date code in this range are not affected by this recall. the gasket of the oil filter becomes more pliable under high temperatures and pressures.

Corrective Action

this condition may cause inadequate sealing and loss of engine oil, possibly resulting in a fire.

Recall Notes

honeywell will replace the affected oil filters free of charge. the recall began during november 2007. owners can contact fram customer service toll-free at 1-800-890-2075.

1993 Am General Hummer

Component

Vehicle Speed Control:Accelerator Pedal

Consequence of Defect

the coating used to protect the accelerator pedal shaft is incompatible with the bronze bushing through which the shaft passes. over time, and in the presence of a corrosive environment (water, road salt), the shaft can corrode inside the bushing increasing the amount of friction between the rotating shaft and the stationary bushing.

Corrective Action

a corroded accelerator pedal shaft can cause the engine throttle to bind and not fully return to idle when the operator's foot is removed from the accelerator pedal increasing the potential for a vehicle accident.

Recall Notes

dealers will install a revised accelerator pedal and shaft assembly.

1993 Am General Hummer

Component

Fuel System, Gasoline:Delivery:Hoses, Lines/Piping, And Fittings

Consequence of Defect

the oil pressure switch which controls the power to the electric fuel pump can fail. failure is due to a missing rubber seal between the switch and the wiring harness. the missing seal allows contaminants to enter the switch causing it to fail in the open or closed position.

Corrective Action

if the switch fails in the closed position, the pump will continue to run when the engine is off, draining the battery. if the switch fails in the open position it will cause poor performance and possibly stalling.

Recall Notes

dealers will inspect the vehicles for the presence of the seal. if the seal is missing, the switch will be replaced and a new seal will be installed.

1993 Am General Hummer

Component

Equipment

Consequence of Defect

certain honeywell fram racing brand hp4 and hp8 oil filters that were manufactured from may 25, 2006, through september 14, 2007, and sold for use as replacement equipment for vehicles list above. the affected filters are marked with a date code a61451 through a72571 sequentially. the date code and part number appear on the filter housing. fram racing hp4 and hp8 oil filters not bearing a date code in this range are not affected by this recall. the gasket of the oil filter becomes more pliable under high temperatures and pressures.

Corrective Action

this condition may cause inadequate sealing and loss of engine oil, possibly resulting in a fire.

Recall Notes

honeywell will replace the affected oil filters free of charge. the recall began during november 2007. owners can contact fram customer service toll-free at 1-800-890-2075.

1993 Am General Hummer

Component

Fuel System, Gasoline:Delivery:Hoses, Lines/Piping, And Fittings

Consequence of Defect

the passenger compartment is separated from the engine compartment by an insulated engine cover. the insulation inside this cover can rub against the fuel return hose resulting in a fuel leak. additionally, a wiring harness can also wear through causing interruption to some electrical operations, including the fuel pump.

Corrective Action

fuel leaking inside the engine compartment can result in a fire when exposed to a source of ignition. failure of the electric fuel pump can cause poor performance and possible stalling creating a road hazard which can result in an accident.

Recall Notes

dealers will replace the rubber fuel line hose with a solid steel lines and route the line to provide one inch of clearance to the cover. also, the wiring harness cover will be replaced and the wiring rerouted to gain sufficient clearance.

1992 Am General Hummer

Component

Vehicle Speed Control:Accelerator Pedal

Consequence of Defect

the coating used to protect the accelerator pedal shaft is incompatible with the bronze bushing through which the shaft passes. over time, and in the presence of a corrosive environment (water, road salt), the shaft can corrode inside the bushing increasing the amount of friction between the rotating shaft and the stationary bushing.

Corrective Action

a corroded accelerator pedal shaft can cause the engine throttle to bind and not fully return to idle when the operator's foot is removed from the accelerator pedal increasing the potential for a vehicle accident.

Recall Notes

dealers will install a revised accelerator pedal and shaft assembly.

1992 Am General Hummer

Component

Fuel System, Gasoline:Delivery:Hoses, Lines/Piping, And Fittings

Consequence of Defect

the oil pressure switch which controls the power to the electric fuel pump can fail. failure is due to a missing rubber seal between the switch and the wiring harness. the missing seal allows contaminants to enter the switch causing it to fail in the open or closed position.

Corrective Action

if the switch fails in the closed position, the pump will continue to run when the engine is off, draining the battery. if the switch fails in the open position it will cause poor performance and possibly stalling.

Recall Notes

dealers will inspect the vehicles for the presence of the seal. if the seal is missing, the switch will be replaced and a new seal will be installed.

1992 Am General Hummer

Component

Equipment

Consequence of Defect

certain honeywell fram racing brand hp4 and hp8 oil filters that were manufactured from may 25, 2006, through september 14, 2007, and sold for use as replacement equipment for vehicles list above. the affected filters are marked with a date code a61451 through a72571 sequentially. the date code and part number appear on the filter housing. fram racing hp4 and hp8 oil filters not bearing a date code in this range are not affected by this recall. the gasket of the oil filter becomes more pliable under high temperatures and pressures.

Corrective Action

this condition may cause inadequate sealing and loss of engine oil, possibly resulting in a fire.

Recall Notes

honeywell will replace the affected oil filters free of charge. the recall began during november 2007. owners can contact fram customer service toll-free at 1-800-890-2075.

1992 Am General Hummer

Component

Fuel System, Gasoline:Delivery:Hoses, Lines/Piping, And Fittings

Consequence of Defect

the passenger compartment is separated from the engine compartment by an insulated engine cover. the insulation inside this cover can rub against the fuel return hose resulting in a fuel leak. additionally, a wiring harness can also wear through causing interruption to some electrical operations, including the fuel pump.

Corrective Action

fuel leaking inside the engine compartment can result in a fire when exposed to a source of ignition. failure of the electric fuel pump can cause poor performance and possible stalling creating a road hazard which can result in an accident.

Recall Notes

dealers will replace the rubber fuel line hose with a solid steel lines and route the line to provide one inch of clearance to the cover. also, the wiring harness cover will be replaced and the wiring rerouted to gain sufficient clearance.